Major Problems with 2001 Volvo S60 Derived from Complaints & Recalls


Custom-fit Add-ons



Worst 3 complaints of 2001 Volvo S60

2001 Volvo S60 TREAD/BELT Victims: 2

2001 Volvo S60 FRONTAL Victims: 1 Mileage: 125000 miles

2001 Volvo S60 ELECTRICAL SYSTEM Mileage: 54868 miles

Browse 2001 Volvo S60 complaints by category

Problems with VEHICLE SPEED CONTROL, FUEL PUMP, FUEL SYSTEM and GASOLINE are the most frequent issues recorded by the NHTSA from Volvo S60 owners.

Problem Category Number of Problems
VEHICLE SPEED CONTROL
throttle module failed leaving me pulling onto interstate but unable to go more than 20 mph before car died. dealer
42
~ 68094 miles
FUEL PUMP > DELIVERY > FUEL SYSTEM, GASOLINE
2001 volvo s60 t5 100 800 miles. the following condition has been intermittent over the last month or so but...
38
~ 78992 miles
FUEL SYSTEM, GASOLINE
i owned a 1991 volvo s60 sedan and i understand you are investigating this car. from time to time as...
28
~ 95833 miles
ELECTRICAL SYSTEM
the vehicle head/tail lights continued to fail due to an electrical problem. *nlm...
25
~ 59614 miles
AUTOMATIC TRANSMISSION > POWER TRAIN
transmission failed at 20 mph. consumer was almost ran over consumer felt this was very dangerous. there was no warning.
16
~ 54850 miles
FUEL/PROPULSION SYSTEM
tl* the contact owns a 2001 volvo s-60. the contact stated that there were strong gasoline fuel fumes coming from...
15
~ 103033 miles
ENGINE > ENGINE AND ENGINE COOLING
dt: consumer stated 2001 volvo s 60 was having a problem with the unit that regulated the air flow into...
7
~ 59087 miles
ENGINE AND ENGINE COOLING
when the vehicle was at idle it shook. the dealership cleaned the throttle but the problem still existed. *nlm after...
6
~ 44971 miles
POWER TRAIN
i had stopped at the traffic light. as i started again on green light the car jerkily jumped forward. i...
5
~ 165087 miles
UNKNOWN OR OTHER
2001 volvo s60. no description given. *jb...
5
~ 40551 miles
SIDEWALL > TIRES
i have replaced 3 pirelli p6 235/45 r17 tires due to bubbling of the sidewall. i complained to the dealer...
4
SEATS
i activated the driver seat heater component on my 2001 volvo s60 during a cold morning. approximately 15 to 20...
3
~ 114548 miles
FUEL PUMP > DELIVERY > FUEL SYSTEM, OTHER
on certain vehicles originally sold in or currently registered in the states of arizona and nevada due to the combination...
3
~ 52333 miles
POWER WINDOW DEVICES AND CONTROLS > VISIBILITY
right front power window inoperable from either side switch control. power door locks do not respond to remote. ambient temprarture
3
~ 92304 miles
LATCH > DOORS > LATCHES/LOCKS/LINKAGES
right front power window inoperable from either side switch control. power door locks do not respond to remote. ambient temprarture
3
~ 59037 miles
FRONTAL > AIR BAGS
consumer states while driving the vehicle at 25mph the vehicle was in a frontal accident with another vehicle. consumer states
3
~ 56000 miles
STRUCTURE
the consumer believes that the vehicle exhibits excessive levels of electromagnetism. *nlm...
3
~ 17194 miles
ENGINE
tl* the contact owns a 2001 volvo s60. while driving at unknown speeds the vehicle stalled and the brakes and...
2
~ 86500 miles
SERVICE BRAKES
when i apply pressure to the brake pedal i get an error message sometimes not always that says "check brake...
2
~ 150500 miles
AIR BAGS
my daughter was stopped at a red light and surrounded by cars on a four lane road. all of sudden...
2
~ 106000 miles
EXTERIOR LIGHTING
right front power window inoperable from either side switch control. power door locks do not respond to remote. ambient temprarture
2
~ 74195 miles
SERVICE BRAKES, HYDRAULIC
dt*: the contact stated the vehicle accelerated on its own after reaching 30 mph and caused an accident. the contact...
2
~ 120500 miles
EMISSION CONTROL > EXHAUST SYSTEM > ENGINE AND ENGINE COOLING
i proceeded to pass a vehicle and lost power could only drive at approx.35m.p.h. i then had to brake and...
2
~ 40000 miles
FUEL SYSTEM, OTHER
2001 volvo s60 2.4t stalled on nj state highway 21 in newark nj due to a failed etm. this resulted...
2
~ 102602 miles
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, GASOLINE
the consumer stated that this is not the complaint she filed her complaint was about her gas tank door coming
2
~ 23000 miles
WINDSHIELD > VISIBILITY
the windshield cracked when water was applied to it while washing the car. *jb...
2
~ 22774 miles
HEAD RESTRAINT > FRONT ASSEMBLY > SEATS
rear seat headrest cannot be repositioned causing poor visibility to driver. dealer has yet to be contacted. *ak *slc...
2
GASOLINE > ENGINE > ENGINE AND ENGINE COOLING
no summary listed for abov evehicle. *ak...
2
~ 14500 miles
STEERING
tl* the contact owns a 2001 volvo s60. while driving at unknown speeds the vehicle stalled and the brakes and...
1
~ 173000 miles
INSTRUMENT CLUSTER/PANEL > ELECTRICAL SYSTEM
tl* the contact owns a 2001 volvo s60. the contact stated that while driving approximately 55 mph the entire instrument...
1
~ 130000 miles
WHEELS
optional wheels (17") corrode so tire breaks seal causing air lose and destruction of tire. our car has about 30
1
~ 7500 miles
SEAT BELTS
2001 volvo s60 passenger side seat belt retractor failed and allowed for the belt to fully release without any tension.
1
~ 166000 miles
SERVICE BRAKES, AIR
lower brake lights fail while upper rear windshield light continues to work. had this work done once in 2005 to...
1
~ 166800 miles
COOLING SYSTEM > ENGINE AND ENGINE COOLING
in october 2007 i inquired of fields volvo of waukesha wisconsin about a malfunctioning temperature gage. the gage would...
1
~ 70201 miles
SUSPENSION
2001 volvo s60 2.4t bought as volvo certified pre-owned from dealer with 47 000 miles. now has 69 170 and...
1
~ 69170 miles
DELIVERY > FUEL SYSTEM, GASOLINE
my volvo s60 is idling very rough. it is not showing any codes but i suspect it's the etm. after...
1
~ 54000 miles
FUSES AND CIRCUIT BREAKERS > WIRING > ELECTRICAL SYSTEM
power outlets inoperable. dealer service replaced fuse (20 amp blade yellow). *nm...
1
~ 54065 miles
HEADLIGHTS > EXTERIOR LIGHTING
lamp outage error text: replaced both headlamp and assembly. *nm...
1
~ 53654 miles
LOWER BALL JOINT > CONTROL ARM > FRONT
dt*: the contact stated while traveling 10 mph the front driver side wheel detached from the vehicle. the vehicle was...
1
~ 63000 miles
TURN SIGNAL > EXTERIOR LIGHTING
2001 volvo s60 stalled while on a major freeway. *kb the turn signal bulbs needed to be replaced. the mass
1
FLOOR SHIFT > LEVER AND LINKAGE > AUTOMATIC TRANSMISSION
dt*: the contact stated while driving at no particular speed the engine oil pressure light illuminated. the vehicle was taken...
1
~ 91000 miles
HYDRAULIC POWER ASSIST SYSTEM > STEERING
tl*the contact owns a 2001 volvo s60. while at the mechanic the power steering reservoir and hose needed to be...
1
~ 50000 miles
LUGS/NUTS/BOLTS > WHEELS
on two family-owned volvo s60 t5's all the wheel bolts have rusted (20 per car 40 total) to the point...
1
CARBURETOR SYSTEM > FUEL SYSTEM, GASOLINE
2001 volvo s60 t5 w/manual transmission stalled abruptly with a "reduced power" message on the dashboard computer display while accelerating...
1
~ 81872 miles
FUEL INJECTION SYSTEM > FUEL SYSTEM, GASOLINE
car was surging while driving. electronic throttle module (etm) was cleaned at cost of $88.00. problem continued until car lost...
1
~ 112699 miles
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC
dt: consumer stated 2001 volvo s 60 was having a problem with the unit that regulated the air flow into...
1
~ 52000 miles
HINGE AND ATTACHMENTS > DOOR > BODY
while at a gas station driver opened the gas tank door and the door sheared off from the plastic hinges.
1
TIRES
pirelli four seasons p6 tire size p235/45 r 17 dot no. xbcuc236 i have had three instances where the tires...
1
WIRING > ELECTRICAL SYSTEM
electrical problem in volvo s60 2001. ts...
1
~ 13000 miles
WHEEL BEARING > FRONT > SUSPENSION
front wheel bearings have been replaced 4 times now with only 17 000 miles on vehicle (2 left & 2
1
~ 7500 miles
TREAD/BELT > TIRES
under normal driving conditions the tire shreadded in the center causing the car to go out of control and injuring...
1
TUBE > TIRES
tube separated from tire causing 3" bubble on sidewall. pirelli was contacted and denied tire warranty as "road hazard" new...
1
FRONT > SUSPENSION
dealer is now handling the case. issue is not with the dealer but with the design of the front suspension.
1
MODULE > IGNITION > ELECTRICAL SYSTEM
the (adaptives/computer system) in the vehicle shut down the engine twice. one situation the driver was riding down a hill
1

Torque wrench

  • EPAuto 1/2-inch Drive Click Torque Wrench, 10~150 ft./lb., 13.6 ~ 203.5 N/m

    EPAuto 1/2-inch Drive Click Torque Wrenc...

    • Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
    • Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
    • Easy to Read: High...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 10~150 Ft-Lb/13.6~203.5 Nm (LX-183)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
    • LONGEVITY -...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 25-250 Ft-Lb/33.9-338.9 Nm (LX-184)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON 3/8-Inch Drive Click Torque Wrench 10~80 Ft-Lb/13.6~108.5 Nm (LX-182)

    LEXIVON 3/8-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON Inch Pound Torque Wrench 1/4-Inch Drive | 20~200 in-lb/2.26~22.6 Nm (LX-181)

    LEXIVON Inch Pound Torque Wrench 1/4-Inc...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • TEKTON 3/8 Inch Drive Micrometer Torque Wrench (10-80 ft.-lb.) 24330

    TEKTON 3/8 Inch Drive Micrometer Torque ...

    • Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
    • Wrench emits a click that can be heard and felt when the preset value is reached
    • Permanently marked, high-contrast dual-range...

Mechanic tool set

  • Crescent 180 Pc. Professional Tool Set in Tool Storage Case - CTK180

    Crescent 180 Pc. Professional Tool Set i...

    • The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
    • Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
    • Get incredible access from combination wrenches with narrow heads,...
  • Craftsman Mechanic Tool Set, 215 Piece, Hand Box Set in Metal, 3 Drawers, Red (CMMT45303)

    Craftsman Mechanic Tool Set, 215 Piece, ...

    • MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
    • VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
  • Craftsman Mechanic Tool Set, 230 Piece with 3 Drawers, Sockets, Extension Bars, Wrenches, Hex Keys, and More (CMMT45305)

    Craftsman Mechanic Tool Set, 230 Piece w...

    • TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
    • OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
  • DEWALT Mechanics Tool Set, 1/4' & 3/8' & 1/2' Drive, SAE/Metric, 205-piece (DWMT81534)

    DEWALT Mechanics Tool Set, 1/4" & 3/8" &...

    • 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
    • Anti-slip driver handle provides maximum comfort
    • Housed in a durable carrying case with metal latches
    • Full-polish chrome for corrosion resistance
  • DEWALT Mechanics Tools Kit and Socket Set, 142-Piece, 1/4 & 3/8' Drive, MM/SAE (DWMT73802)

    DEWALT Mechanics Tools Kit and Socket Se...

    • Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
    • Ratchets include a low profile directional lever to help reduce catch points and for easy...
  • Amazon Basics Mechanic's Tool Set with Chrome Finish and Case - Set of 201 Pieces

    Amazon Basics Mechanic's Tool Set with C...

    • Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
    • Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
    • Both metric...

Tool box

  • TUFFIOM 8-Drawer Rolling Tool Chest w/Lock & Key, Tool Storage Cabinet w/Wheels, Detachable Top, Drawers, Side Hooks & Drawer Liners, Tool Organizer Box for Garage, Warehouse & Repair Shop, Red

    TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...

    • LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
  • beyond by BLACK+DECKER BLACK+DECKER BDST60500APB Stackable Storage System - 3 Piece Set (Small Toolbox, Deep Toolbox, and Rolling Tote)

    beyond by BLACK+DECKER BLACK+DECKER BDST...

    • Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
    • Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
  • BIG RED ANTBD133-XB Torin 20' Portable 3 Drawer Steel Tool Box with Metal Latch Closure, Red

    BIG RED ANTBD133-XB Torin 20" Portable 3...

    • Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
    • Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
  • DEKOPRO 228 Piece Socket Wrench Auto Repair Tool Combination Package Mixed Tool Set Hand Tool Kit with Plastic Toolbox Storage Case

    DEKOPRO 228 Piece Socket Wrench Auto Rep...

    • HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
    • COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
  • Torin 17-Inch Plastic Tool Box,3-Tiers Multi-Function Storage Portable Toolbox Organizer, Black/Orange ATRJH-3430T

    Torin 17-Inch Plastic Tool Box,3-Tiers M...

    • Tough metal latches are solid and easy to open and close, with long use life
    • Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
  • CARTMAN 148 Piece Automotive and Household Tool Set - Perfect for Car Enthusiasts and DIY Home Repairs

    CARTMAN 148 Piece Automotive and Househo...

    • Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
    • Durable and Corrosion-Resistant: All tools in the kit...


2001 Volvo S60 specs
Compare

Exterior

Bulbs

Maintenance

Complaints

Forgive our ad-diction! It's just our funky little way of keeping the lights on. Bear with us!

Discussion