Major Problems with 2004 Volkswagen Touareg Derived from Complaints & Recalls


Custom-fit Add-ons



Worst 3 complaints of 2004 Volkswagen Touareg

2004 Volkswagen Touareg ENGINE Victims: 1

2004 Volkswagen Touareg AIR BAGS Victims: 1

2004 Volkswagen Touareg POWER ADJUST Victims: 1

Browse 2004 Volkswagen Touareg complaints by category

Problems with ELECTRICAL SYSTEM, AUTOMATIC TRANSMISSION and PRESSURE MONITORING AND REGULATING SYSTEMS are the most frequent issues recorded by the NHTSA from Volkswagen Touareg owners.

Problem Category Number of Problems
ELECTRICAL SYSTEM
the electronic safety program module malfunctioned. as a result driver lost control of the vehicle while driving 65 mph.*ak...
33
~ 39344 miles
AUTOMATIC TRANSMISSION > POWER TRAIN
my 2004 vw touareg has a serious safety issue with its transmission. when accelerating from a stop or low speed...
26
~ 27647 miles
PRESSURE MONITORING AND REGULATING SYSTEMS > TIRES
tire monitoring system failed. this is a recurring problem hopefully will soon be classified as a recall. i have taken...
23
~ 17840 miles
FUEL/PROPULSION SYSTEM
in previous weeks several intermittent mil lights for loose gas cap came on and off. checked codes found "large evap...
20
~ 74061 miles
AIR BAGS
air bag warning light came on and stayed on. volkswagen says they need to develop a new harness. they've had...
19
~ 102354 miles
VEHICLE SPEED CONTROL
the vehicle occasionally hesitated badly on acceleration from a stop. *ph (consumer letter add to received on 04/26/2004). *mr consumer
17
~ 14712 miles
SUSPENSION
volkswagen touareg 2004 does not stop in inclement weather. *bf all four tires were practically bald and the vehicle needed...
12
~ 15677 miles
TIRES
tires on suv does not support the weight of the vehicle. *bf the consumers 2004 vw toureg needed new tires...
12
~ 20067 miles
STEERING
i have recently purchased a 2004 volkswagen tuareg without driving the vehicle off the parking lot i took it straight...
12
~ 48067 miles
POWER TRAIN
i have a 2004 vw touareg v8 i have a airbag light that come on (airbag fault) now the tran
11
~ 961409 miles
SERVICE BRAKES, HYDRAULIC
while pulling into the apt. parking lot the brakes failed and the steering wheel locked there was an alert on...
10
~ 8245 miles
ENGINE AND ENGINE COOLING
my vehicle has an electronic throttle control which is extremely sensitive and from a standing start does not respond to...
10
~ 13731 miles
FRONT > SUSPENSION
door handles stick on all four doors. last year my husband was in the passenger seat as i went around...
7
~ 35789 miles
EXTERIOR LIGHTING
while driving at night on the garden state parkway at 65mph all of the lights both exterior and interior went...
6
~ 78389 miles
ENGINE
car stalls skips gears jerks when coming from a full stop to accelerating jerks and pull really hard going into...
6
~ 73781 miles
ENGINE > ENGINE AND ENGINE COOLING
2004 vw touareg v8. these vehicles exhibits frequent but inconsistent delay in throttle response. this issue arises most often in...
6
~ 8423 miles
ACCELERATOR PEDAL > VEHICLE SPEED CONTROL
2004 vw touareg v8. these vehicles exhibits frequent but inconsistent delay in throttle response. this issue arises most often in...
6
~ 10824 miles
UNKNOWN OR OTHER
i was driving a short distance from my house (2 miles) when i noticed my car not driving normally. i...
5
~ 2003857 miles
FUEL SYSTEM, GASOLINE
2004 vw touareg with tire failure and key programming. consumer states he had to replace the tires due to a...
5
~ 78528 miles
LATCH > DOORS > LATCHES/LOCKS/LINKAGES
my 2004 touareg with less than 5000 miles has been in for servicing 7 times. the brakes have been worked...
5
~ 5400 miles
STRUCTURE
while traveling with sun roof open vibration inside of vehicle hurt consumer's ears.*ak...
5
~ 35057 miles
ELECTRONIC STABILITY CONTROL
wouldn't start so had it towed to northland volkswagen. there they tested and said i needed steering column replaced and...
4
~ 54528 miles
DRIVELINE > POWER TRAIN
drive train failed within warranty period. also the module failed within six months of the drive train being replaced. the...
4
~ 51238 miles
WINDSHIELD WIPER/WASHER > VISIBILITY
the touareg has two defcts that will eventually lead to if they have not caused damge. for months i have...
4
~ 18260 miles
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC
on two occasions my 2004 volkswagen touareg v-8 experienced complete electrical system failures. the vehicle would not start on these...
4
~ 9100 miles
CONTROL MODULE (TCM, PCM) > AUTOMATIC TRANSMISSION > POWER TRAIN
transmission has terrible shift characteristics. unless the vehicle is completely stopped the transmission won't downshift to 1st or when it...
4
~ 328 miles
SENSOR/CONTROL MODULE > FRONTAL > AIR BAGS
air bag warning light has come on 4 times indicating a failure in the system. vw has been unable to...
4
~ 14250 miles
WIRING > ELECTRICAL SYSTEM
electrical wiring harness was mounted too close to the manifold. the clamp for these wires became too hot and caused
4
~ 29795 miles
FUEL INJECTION SYSTEM > FUEL SYSTEM, GASOLINE
2004 tourag has a hestiency in starting causing the vehcile to not move immediately and then surge forward. we also...
4
~ 25195 miles
SERVICE BRAKES
tl* the contact owns a 2004 volkswagen touareg. the contact stated that he took the vehicle to the dealer for...
3
~ 92448 miles
LATCHES/LOCKS/LINKAGES
unexpected and sudden electrical malfunction of the steering column lock causing the vehicle to shut down unable to start or
3
~ 57850 miles
ELECTRICAL > EQUIPMENT
i am having trouble with my vw touareg v6. since then i have had numerous visits to the dealer for...
3
~ 4895 miles
WHEELS
driver applied the brakes and pedal went to the floor and the steering wheel failed to turn. driver lost control...
3
~ 3667 miles
EQUIPMENT
the touareg has two defcts that will eventually lead to if they have not caused damge. for months i have...
3
~ 8333 miles
TRANSFER CASE (4-WHEEL DRIVE) > POWER TRAIN
on two occasions my 2004 volkswagen touareg v-8 experienced complete electrical system failures. the vehicle would not start on these...
3
~ 27347 miles
HEADLIGHTS > EXTERIOR LIGHTING
i took delivery of my 2004 vw touareg on 7-11-04. by 9-9-04 it was having problems. it has been in...
3
~ 25367 miles
INTERIOR/UNDER DASH > WIRING > ELECTRICAL SYSTEM
to whom it may concern i drive a 2004 vw touareg. i want to report a technical problem regarding the...
3
~ 3600 miles
FRONTAL > AIR BAGS
steering wheel airbag module (horn area) "popped" out of place while the car was parked. airbag module was then no
3
~ 1167 miles
12V/24V/48V BATTERY > ELECTRICAL SYSTEM
2004 touareg that has experienced multiple battery failures due to excessive draw. the vehicle cannot be left unattended for more...
3
~ 18707 miles
VISIBILITY/WIPER
i was driving on 101 south from santa rosa towards san francisco and when in the novato area the rearview...
2
~ 60748 miles
SEAT BELTS
rear middle seat belt was jammed after folding down the rear seat. *tr...
2
~ 95000 miles
BODY > STRUCTURE
tl* the contact owns a 2004 volkswagen touareg. the contact stated that whenever it rained she would find standing water...
2
~ 45000 miles
GASOLINE > ENGINE > ENGINE AND ENGINE COOLING
i bought a 2004 volkswagen touareg new and treated it like a baby. dealer service never off-road. at 80 000...
2
~ 40000 miles
TREAD/BELT > TIRES
on my 2004 touareg with 12500 miles on it all four tires (that came with the vehicle when i bought
2
AIR CONDITIONER > APPLIANCE > EQUIPMENT
2004 volkswagen touareg has a burning odor coming from the vents. *mr the consumer attempted to turn on the a/c...
2
REAR/OTHER > SEAT BELTS
1.the clock on the dashboard: the time is running almost 1 minute faster per day. if you dont fix it...
2
PARKING BRAKE
i took delivery of my 2004 vw touareg on 7-11-04. by 9-9-04 it was having problems. it has been in...
2
~ 23303 miles
DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY
the consumer stated the defogger did not defrost the windshield efficiently. this caused poor visibility to the driver. the consumer...
2
~ 9940 miles
EMISSION CONTROL > EXHAUST SYSTEM > ENGINE AND ENGINE COOLING
tl* the contact owns a 2004 volkswagen touareg. the contact stated that the oxygen sensor emmissions warning light remained illuminated....
1
~ 134447 miles
SWITCH > IGNITION > ELECTRICAL SYSTEM
tl* the contact owns a 2004 volkswagen touareg. the contact stated the gear shift selector would not move out of...
1
~ 75285 miles
FLOOR SHIFT > LEVER AND LINKAGE > AUTOMATIC TRANSMISSION
tl* the contact owns a 2004 volkswagen touareg. the contact stated the gear shift selector would not move out of...
1
~ 75285 miles
COOLING SYSTEM > ENGINE AND ENGINE COOLING
multiple engine light failures for over 4 years. engine light came on and engine shut down immediately while wife was...
1
~ 44000 miles
INSTRUMENT CLUSTER/PANEL > ELECTRICAL SYSTEM
tl*- the contact stated that while driving the 2004 volkswagen torgue with 31000 failure mileage at any rate of speed...
1
~ 31000 miles
STARTER ASSEMBLY > ELECTRICAL SYSTEM
if i drive the car for one hour and turn the engine off when trying to restart the engine the...
1
~ 31000 miles
EXHAUST SYSTEM > ENGINE AND ENGINE COOLING
i have had my 2004 vw touareg since june 2006 and have had problem after problem with the vehicle. the...
1
REAR WINDOW WIPER/WASHER > VISIBILITY
i brought a volkswagen touareg. this vehicle has a lot problems with the brake and engine. so i filed a...
1
~ 300 miles
SUPPORT DEVICE/STRUT > HATCHBACK/LIFTGATE > BODY
our 2004 vw touareg v-8 has the following problems despite five trips to the dealer: i) hesitation during acceleration ii)...
1
IGNITION > ELECTRICAL SYSTEM
my 2004 v6 volkswagen touareg frequently stalls after the engine is cranked. this has been a problem since we purchased...
1
~ 5000 miles
ALTERNATOR/GENERATOR/REGULATOR > ELECTRICAL SYSTEM
my 2004 v8 touareg is absolutely the biggest lemon ever built. it has been in the dealership for 11 full...
1
~ 10000 miles
AIR SUSPENSION SYSTEM > SPRINGS > REAR
my 2004 v8 touareg is absolutely the biggest lemon ever built. it has been in the dealership for 11 full...
1
~ 10000 miles
TRAILER HITCHES
the touareg has two defcts that will eventually lead to if they have not caused damge. for months i have...
1
~ 25000 miles
LINKAGES > WINDSHIELD WIPER/WASHER > VISIBILITY
this headlight washer(s) that pop up from front bumper came off during drive from ca to md. during the drive...
1
~ 19000 miles
DRIVESHAFT > DRIVELINE > POWER TRAIN
2004 vw touareg with tire failure and key programming. consumer states he had to replace the tires due to a...
1
SIDEWALL > TIRES
2004 vw touareg with tire failure and key programming. consumer states he had to replace the tires due to a...
1
HYDRAULIC > POWER ASSIST > SERVICE BRAKES, HYDRAULIC
my 2004 touareg with less than 5000 miles has been in for servicing 7 times. the brakes have been worked...
1
~ 2000 miles
SEATS
1.the clock on the dashboard: the time is running almost 1 minute faster per day. if you dont fix it...
1
BELTS AND ASSOCIATED PULLEYS > GASOLINE > ENGINE
consumer complained about intermittent stalling. when driving on the highway at approximately 60 mph vehicle stalled as if the motor...
1
~ 19165 miles
VISIBILITY
dt: the consumer states his 2004 volkswagen touareg was having a throttle delay problem. this is especially bad when pulling...
1
~ 200 miles
HORN > ELECTRICAL SYSTEM
while driving srs air bag light appeared on the dashboard and remained on. consumer pressed down on the horn an...
1
RECLINER > FRONT ASSEMBLY > SEATS
dt: the problem began on 4-04. problems with brakes. hydraulic brakes are pulling causing excessive screeching noise and brake dust....
1
~ 5400 miles
MANUAL TRANSMISSION > POWER TRAIN
transmisson fails to engage when starting from a slow roll or stop. dealer has been unable to reproduce intermittent problem....
1
~ 1000 miles
POWER ADJUST > FRONT ASSEMBLY > SEATS
passenger sitting behind driver in 2004 volkswagen toureg was injured when driver left the car. electric seat retracted back and...
1
PADS > DISC > FOUNDATION COMPONENTS
since i purchased a 2004 vw touareg on 2/28/04 i have had various problems with it. the most severe is...
1
~ 150 miles
LOWER ARM > CONTROL ARM > FRONT
tl* the contact owns a 2004 volkswagen touareg. while driving at 25 mph the contact observed that the vehicle was...
1
~ 39000 miles

Torque wrench

  • EPAuto 1/2-inch Drive Click Torque Wrench, 10~150 ft./lb., 13.6 ~ 203.5 N/m

    EPAuto 1/2-inch Drive Click Torque Wrenc...

    • Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
    • Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
    • Easy to Read: High...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 10~150 Ft-Lb/13.6~203.5 Nm (LX-183)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
    • LONGEVITY -...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 25-250 Ft-Lb/33.9-338.9 Nm (LX-184)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON 3/8-Inch Drive Click Torque Wrench 10~80 Ft-Lb/13.6~108.5 Nm (LX-182)

    LEXIVON 3/8-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON Inch Pound Torque Wrench 1/4-Inch Drive | 20~200 in-lb/2.26~22.6 Nm (LX-181)

    LEXIVON Inch Pound Torque Wrench 1/4-Inc...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • TEKTON 3/8 Inch Drive Micrometer Torque Wrench (10-80 ft.-lb.) 24330

    TEKTON 3/8 Inch Drive Micrometer Torque ...

    • Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
    • Wrench emits a click that can be heard and felt when the preset value is reached
    • Permanently marked, high-contrast dual-range...

Mechanic tool set

  • Crescent 180 Pc. Professional Tool Set in Tool Storage Case - CTK180

    Crescent 180 Pc. Professional Tool Set i...

    • The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
    • Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
    • Get incredible access from combination wrenches with narrow heads,...
  • Craftsman Mechanic Tool Set, 215 Piece, Hand Box Set in Metal, 3 Drawers, Red (CMMT45303)

    Craftsman Mechanic Tool Set, 215 Piece, ...

    • MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
    • VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
  • Craftsman Mechanic Tool Set, 230 Piece with 3 Drawers, Sockets, Extension Bars, Wrenches, Hex Keys, and More (CMMT45305)

    Craftsman Mechanic Tool Set, 230 Piece w...

    • TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
    • OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
  • DEWALT Mechanics Tool Set, 1/4' & 3/8' & 1/2' Drive, SAE/Metric, 205-piece (DWMT81534)

    DEWALT Mechanics Tool Set, 1/4" & 3/8" &...

    • 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
    • Anti-slip driver handle provides maximum comfort
    • Housed in a durable carrying case with metal latches
    • Full-polish chrome for corrosion resistance
  • DEWALT Mechanics Tools Kit and Socket Set, 142-Piece, 1/4 & 3/8' Drive, MM/SAE (DWMT73802)

    DEWALT Mechanics Tools Kit and Socket Se...

    • Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
    • Ratchets include a low profile directional lever to help reduce catch points and for easy...
  • Amazon Basics Mechanic's Tool Set with Chrome Finish and Case - Set of 201 Pieces

    Amazon Basics Mechanic's Tool Set with C...

    • Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
    • Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
    • Both metric...

Tool box

  • TUFFIOM 8-Drawer Rolling Tool Chest w/Lock & Key, Tool Storage Cabinet w/Wheels, Detachable Top, Drawers, Side Hooks & Drawer Liners, Tool Organizer Box for Garage, Warehouse & Repair Shop, Red

    TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...

    • LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
  • beyond by BLACK+DECKER BLACK+DECKER BDST60500APB Stackable Storage System - 3 Piece Set (Small Toolbox, Deep Toolbox, and Rolling Tote)

    beyond by BLACK+DECKER BLACK+DECKER BDST...

    • Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
    • Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
  • BIG RED ANTBD133-XB Torin 20' Portable 3 Drawer Steel Tool Box with Metal Latch Closure, Red

    BIG RED ANTBD133-XB Torin 20" Portable 3...

    • Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
    • Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
  • DEKOPRO 228 Piece Socket Wrench Auto Repair Tool Combination Package Mixed Tool Set Hand Tool Kit with Plastic Toolbox Storage Case

    DEKOPRO 228 Piece Socket Wrench Auto Rep...

    • HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
    • COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
  • Torin 17-Inch Plastic Tool Box,3-Tiers Multi-Function Storage Portable Toolbox Organizer, Black/Orange ATRJH-3430T

    Torin 17-Inch Plastic Tool Box,3-Tiers M...

    • Tough metal latches are solid and easy to open and close, with long use life
    • Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
  • CARTMAN 148 Piece Automotive and Household Tool Set - Perfect for Car Enthusiasts and DIY Home Repairs

    CARTMAN 148 Piece Automotive and Househo...

    • Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
    • Durable and Corrosion-Resistant: All tools in the kit...


2004 Volkswagen Touareg specs
Compare

Exterior

Bulbs

Maintenance

Complaints

Forgive our ad-diction! It's just our funky little way of keeping the lights on. Bear with us!

Discussion