Major Problems with 2002 Toyota RAV4 Derived from Complaints & Recalls
Custom-fit Add-ons
Worst 3 complaints of 2002 Toyota RAV4
2002 Toyota RAV4
AIR BAGS
Victims: 6
Mileage: 33000 miles
2002 Toyota RAV4
RACK AND PINION
Victims: 5
Mileage: 26000 miles
2002 Toyota RAV4
VEHICLE SPEED CONTROL
Victims: 3
Mileage: 60000 miles
Browse 2002 Toyota RAV4 complaints by category
Problems with AUTOMATIC TRANSMISSION, POWER TRAIN and ELECTRICAL SYSTEM are the most frequent issues recorded by the NHTSA from Toyota RAV4 owners.
Problem Category | Number of Problems |
AUTOMATIC TRANSMISSION > POWER TRAIN when driving up a hill vehicle began to stall. *ak... |
254
~ 106019 miles |
POWER TRAIN ces light came on. trans started slipping. took to dealer. diagnosed known ecm problem. performed toyota recommended ecm update but... |
112
~ 95880 miles |
ELECTRICAL SYSTEM when driving for more than 15 miles and stopping the vehicle shakes. took vehicle to dealer and they stated that... |
88
~ 91419 miles |
VEHICLE SPEED CONTROL re: fuel throttle linkage failure: high idle speed unpredictable idle speed oscillation / surges unpredictable acceleration / deceleration (particularly when... |
33
~ 84784 miles |
ENGINE AND ENGINE COOLING i have a 2002 toyota rav 4. i have taken my car to the dealer for the changes of oil... |
23
~ 84415 miles |
UNKNOWN OR OTHER a "baffle" is installed into the oil filler cap beginning with the 2002 toyota's. while driving the "baffle" broke |
23
~ 88579 miles |
ENGINE we had just left a parking lot in our 2002 rav 4 and as we came up to speed the... |
21
~ 83442 miles |
AIR BAGS while traveling at 25 mph vehicle was involved in a head on collision and airbags did not deploy. dealer notified. |
17
~ 43471 miles |
ELECTRONIC STABILITY CONTROL i am writing to complain about a defect in the 2002 toyota rav4 that i feel could be very dangerous.... |
16
~ 99723 miles |
ENGINE > ENGINE AND ENGINE COOLING dt*: the contact stated while driving 45 mph the vehicle stalled without warning. the vehicle was taken to a service... |
13
~ 91898 miles |
STEERING steering column will steer to left and right and the vehicle is uncontrollable in traffic. dealership is aware of problem.*ak... |
7
~ 51027 miles |
LATCHES/LOCKS/LINKAGES the rear luggage cover does not stay up and numerous times it has slipped and hit me or one of... |
5
~ 49800 miles |
FRONTAL > AIR BAGS while traveling 35 mph tires somehow got caught between pavement/grove on side of road. truck then pulled to right and... |
5
~ 40420 miles |
CONTROL MODULE (TCM, PCM) > AUTOMATIC TRANSMISSION > POWER TRAIN hard shift prob from 2/3rd gear with toyota 2002 rav4 took car to dealer on 9-17-2007. recall for emission problem... |
4
~ 98606 miles |
FUEL SYSTEM, GASOLINE when the brake was applied the vehicle surged foward due to fuel throttle leakage. dealer notified. *jb... |
4
~ 68432 miles |
ELECTRICAL > EQUIPMENT the toyota rav4 (year 2002) indiscriminately speeds up and maxes out the rpms (6000) for not reason. i was going... |
3
~ 119575 miles |
SERVICE BRAKES, HYDRAULIC when shifting from drive to reverse and vice versa a clanging sound is heard from the front. i took car... |
3
~ 22369 miles |
TIRES defective tires vehicle jack equipment. while driving one of the vehicle's tire exploded when it ran over an orange in... |
3
~ 58000 miles |
SUSPENSION while traveling 35 mph tires somehow got caught between pavement/grove on side of road. truck then pulled to right and... |
3
~ 40909 miles |
MANUAL TRANSMISSION > POWER TRAIN my 2002 toyota rav4 w/5 speed standard transmission pops out of 5th gear at highway speed causing sudden deceleration and... |
2
~ 113483 miles |
EQUIPMENT i have a toyota rav4 2002-in may 2006 i went to military training school i got back oct 2006 while... |
2
~ 100000 miles |
EXHAUST SYSTEM > ENGINE AND ENGINE COOLING this is my third toyota. i have never owned a toyota that smokes. i park my toyota rav 4 for... |
2
~ 30500 miles |
STRUCTURE the bolts in the roof rack fall out. we have never used the roof rack. over the past 3 years... |
2
~ 40000 miles |
ACCELERATOR PEDAL > VEHICLE SPEED CONTROL when backing up the vehicle either accelerated or the gas pedal got stuck. ts... |
2
|
FRONT UNDERHOOD > WIRING > ELECTRICAL SYSTEM engine compartment caught on fire right after consumer parked vehicle. contacted dealer and the dealer was not willing to do |
2
~ 20000 miles |
EXTERIOR LIGHTING check engine light constantly comes on but after checking no issues are tound... |
1
|
FUEL/PROPULSION SYSTEM i was driving my rav4 down my road when i suddenly lost control of the accelerator with my foot on... |
1
~ 134000 miles |
SEAT BELTS takata recall: i was involved in a head-0n collision and my air bags did not deflate like they were supposed... |
1
~ 33000 miles |
UNDERBODY SHIELDS > FRAME AND MEMBERS > STRUCTURE front subframe rusted and rotted through. called toyota and filed a claim but no real help as i was the... |
1
|
EQUIPMENT ADAPTIVE/MOBILITY i have a toyota rav4 2002. i am now experiencing a nightmare. a few weeks ago my car started shifting... |
1
|
FRAME AND MEMBERS > STRUCTURE i have a '02 toyota rav 4 whose k- frame which supports the front wheels and steering mechanism rusted completely... |
1
~ 150000 miles |
INTERIOR LIGHTING in the beginning of june i noticed my rav4 would slightly pause when i pres the gas pedal and would... |
1
~ 91000 miles |
MECHANICAL > EQUIPMENT the toyota rav4 (year 2002) indiscriminately speeds up and maxes out the rpms (6000) for not reason. i was going... |
1
~ 183000 miles |
SERVICE BRAKES, ELECTRIC i have a 2002 toyota rave 4 i have even complained to the dealership where i bought the vehicle. i... |
1
|
LINKAGES > WINDSHIELD WIPER/WASHER > VISIBILITY during heavy rain storm passenger side wiper linkage/mechanism broke. luckily this was while the blade was on the down stroke... |
1
~ 88000 miles |
SIDE/WINDOW > AIR BAGS dt*: the contact stated while driving 10 mph the vehicle was broadsided on the driver side. the side airbag did... |
1
~ 100000 miles |
EXTERNAL > WARNINGS > BACK OVER PREVENTION i have a 2002 toyota rav 4. i have taken my car to the dealer for the changes of oil... |
1
~ 45100 miles |
RACK AND PINION > STEERING while driving a clicking noise came from front of the vehicle. the steering failed to turn properly and the driver... |
1
~ 26000 miles |
WIRING > ELECTRICAL SYSTEM i had driven about 3 miles then got stuck in a traffic jam. at that time i could smell something... |
1
~ 27000 miles |
CATALYTIC CONVERTOR > EMISSION CONTROL > EXHAUST SYSTEM my 02 toyota rav4 check engine light comes on and i found out that my o2 sensors are reading below... |
1
|
BUMPERS > BODY > STRUCTURE i drive a 2002 toyota rav4. i was stopped at a stop light and when the light turned green i... |
1
~ 17000 miles |
REAR > SUSPENSION drivers side rear wheel has extreme toe-out. have observed this condition on all 2002 viewed 2wd and 4wd.causes extreme tire |
1
|
HEADLIGHTS > EXTERIOR LIGHTING on july 7 2003 i was on my way to work when the battery discharge light came on and i... |
1
~ 1189 miles |
BELTS AND ASSOCIATED PULLEYS > GASOLINE > ENGINE on july 7 2003 i was on my way to work when the battery discharge light came on and i... |
1
~ 1189 miles |
IGNITION > ELECTRICAL SYSTEM on july 7 2003 i was on my way to work when the battery discharge light came on and i... |
1
~ 1189 miles |
12V/24V/48V BATTERY > ELECTRICAL SYSTEM on july 7 2003 i was on my way to work when the battery discharge light came on and i... |
1
~ 1189 miles |
ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT > MECHANICAL > EQUIPMENT defective tires vehicle jack equipment. while driving one of the vehicle's tire exploded when it ran over an orange in... |
1
~ 5000 miles |
DELIVERY > FUEL SYSTEM, OTHER the dashboard rattles when driving. took to dealer and the dealer has replaced the dashboard about four times. the dash |
1
|
GASOLINE > ENGINE > ENGINE AND ENGINE COOLING when driving for more than 15 miles and stopping the vehicle shakes. took vehicle to dealer and they stated that... |
1
|
MASTER CYLINDER > FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC while stopping down a hill the consumer noticed the brake pedal continued to travel to floorboard. dealer serviced vehicle and |
1
~ 20000 miles |
RETRACTOR > FRONT > SEAT BELTS while traveling 35 mph tires somehow got caught between pavement/grove on side of road. truck then pulled to right and... |
1
|
GLASS, SIDE/REAR > VISIBILITY by accident i put my driver's side rear window approx. 1/2 way down . unknowingly i left the window down.... |
1
|
CARRIER/RACK > MECHANICAL > EQUIPMENT re: fuel throttle linkage failure: high idle speed unpredictable idle speed oscillation / surges unpredictable acceleration / deceleration (particularly when... |
1
|
Torque wrench
-
EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...
Mechanic tool set
-
Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
-
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
-
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
-
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
-
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
-
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...
Tool box
-
TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
-
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
-
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
-
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
-
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
-
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...
Discussion