Major Problems with 2004 Toyota Corolla Derived from Complaints & Recalls


Custom-fit Add-ons



Worst 3 complaints of 2004 Toyota Corolla

2004 Toyota Corolla FRONTAL Victims: 6 Mileage: 133000 miles

2004 Toyota Corolla VEHICLE SPEED CONTROL Victims: 5

2004 Toyota Corolla SEAT BELTS Victims: 4

Browse 2004 Toyota Corolla complaints by category

Problems with AIR BAGS, VEHICLE SPEED CONTROL and ELECTRICAL SYSTEM are the most frequent issues recorded by the NHTSA from Toyota Corolla owners.

Problem Category Number of Problems
AIR BAGS
i drive a 2004 toyota corolla le with approximately 900 miles and rear ended at 1993 honda accord. upon impact...
210
~ 29675 miles
VEHICLE SPEED CONTROL
i bought a brand new 2004 toyota corolla in may this year. a few days later i was driving on...
57
~ 44295 miles
ELECTRICAL SYSTEM
on three occasions the vehicle would not start as a result of a drained battery. 1st time the dealer replaced...
17
~ 57597 miles
UNKNOWN OR OTHER
the molding piece seperating from around the radio. my car was 3 months old when the problem was noticed. i...
14
~ 23866 miles
FRONTAL > AIR BAGS
while trying to make a left turn vehicle was hit in front end and front air bags did not deploy.
13
~ 30888 miles
SEAT BELTS
consumer request for a seat belt extender for 2005 4dr corolla le. *bf *jb...
11
~ 50274 miles
ENGINE AND ENGINE COOLING
2004 corolla ce has horrible rotten egg smell car has only 550 miles on it. dealer say to switch gas
11
~ 47986 miles
CATALYTIC CONVERTOR > EMISSION CONTROL > EXHAUST SYSTEM
2004 toyota corolla: emission of hydrogen sulfide gas from exhaust system.*ak...
11
~ 342 miles
STEERING
steering wheel is not in proper position. it is turned to the left. when i try to turn it into
11
~ 52177 miles
FUEL SYSTEM, GASOLINE
two weeks after purchasing my 2004 toyota corolla le i started to notice a "rotten egg" smell. it is awful...
10
~ 61282 miles
EXHAUST SYSTEM > ENGINE AND ENGINE COOLING
2004 corolla bought 32 days ago with 92 miles. noticed sulfur smell when exiting vehicle only after first refill --...
10
~ 1453 miles
ENGINE
every time it rains and creates a water puddle on the road when i drive my car through it water...
9
~ 99449 miles
POWER TRAIN
i was driving at 70 mph on the interstate when the car stalled out. we were able to pull to...
9
~ 110278 miles
VISIBILITY
tl*the contact owns a 2004 toyota corolla. she stated that the driver-side window completely shattered when she rolled it up....
9
~ 43231 miles
POWER WINDOW DEVICES AND CONTROLS > VISIBILITY
upon opening driver's power window it shattered completely and had to be replaced. *tr ...
7
~ 57648 miles
GLASS, SIDE/REAR > VISIBILITY
i was driving a toyota 2004 corolla on the highway @ 60 mph. all the car windows were open. there...
5
~ 29939 miles
WHEELS
took my 2004 toyota corolla le to dealer with complaint of steering wheel vibration at 60-70 mph. dealer stated that...
5
~ 49417 miles
TIRES
consumer will provide further information. good year. model# size# dot# and how the tire blew up. por favor denos mas
5
~ 11993 miles
ENGINE > ENGINE AND ENGINE COOLING
unexpected and without warning while car is in drive and stopped in traffic or at red light engine idle speed...
5
~ 33136 miles
EMISSION CONTROL > EXHAUST SYSTEM > ENGINE AND ENGINE COOLING
2004 corolla: emission of hydrogen sulfide gas from exhaust system.*ak...
5
~ 496 miles
LATCHES/LOCKS/LINKAGES
the lock cylinders on both front doors have malfunctioned. the passenger side (which i rarely use) will no longer unlock...
4
~ 51728 miles
AUTOMATIC TRANSMISSION > POWER TRAIN
i am having what could be a serious problem with my almost new corolla 2004 with only 8000 miles. if...
4
~ 31089 miles
ELECTRONIC STABILITY CONTROL
my 2004 toyota corolla surges for 1-2 seconds while at stop or red light. it feels like it is going...
4
BODY > STRUCTURE
metalic rattle comes out of the dashboard of 2004 corolla le. the car has only 15 miles on it.*ak...
4
~ 27 miles
FUEL/PROPULSION SYSTEM
tl* the contact owns a 2004 toyota corolla. the contact stated that there were small metal fragments around the fuel...
3
~ 97167 miles
SERVICE BRAKES
tl* the contact owns a 2004 toyota corolla. the contact stated while attempting to decelerate the brakes failed to function....
3
~ 71333 miles
EXTERIOR LIGHTING
internal fogging of both headlamp lens. the replacement requires replacing the entire headlight assembly at a ridiculous cost. *tr...
3
~ 39000 miles
PARKING BRAKE
on feburary 12 2010 my 2005 toyota corolla was parked and running while i brought groceries into my home. when...
3
~ 22506 miles
EQUIPMENT ADAPTIVE/MOBILITY
10/29/09 i turned on the ignition and the engined immediately revved into the danger zone. i was not able to...
3
~ 31167 miles
MANUAL TRANSMISSION > POWER TRAIN
my daughter was driving her 2004 toyota corolla from san diego to dallas. about 60 miles east of yuma az...
3
~ 78333 miles
FILLER PIPE AND CAP > TANK ASSEMBLY > STORAGE
dt*: the contact stated that the gas filler tube had rust due to defective material. the vehicle was taken to...
3
~ 19171 miles
FUEL SYSTEM, OTHER
at first i noticed the gas tank would not fill properly. i thought it was not venting properly but i...
3
~ 27667 miles
SUN/MOON ROOF ASSEMBLY > VISIBILITY
while driving vehicle sunroof glass separated from the sunroof mechanism. *bf the dealer determined that the glue used to hold
3
~ 66667 miles
SEATS
i bought a toyota corolla 2004 sedan from gordie boucher nissan 10606 w. arthur avenue west allis wisconsin phone no....
3
~ 44597 miles
HEADLIGHTS > EXTERIOR LIGHTING
appears that the drl system mandated by dot can not be deactivated. all military installations madate that a vehicle's headlights...
3
~ 41000 miles
SERVICE BRAKES, HYDRAULIC
the air bag light appeared on the dashboard until the vehicle was turned off. the driver had taken the vehicle...
3
~ 15395 miles
VISIBILITY/WIPER
tl* takata recall. the contact owns a 2004 toyota corolla. the contact received notification of nhtsa campaign numbers: 15v285000 (air...
2
~ 118500 miles
BELTS AND ASSOCIATED PULLEYS > GASOLINE > ENGINE
2004 toyota corolla drive belt cracked at about 5k miles i have a 2004 corolla which is maintained regularly at...
2
~ 16500 miles
AIR CONDITIONER > APPLIANCE > EQUIPMENT
a/c failed stopped cooling the clutch is inoperative a/c clutch does not engage. *nm...
2
~ 22000 miles
SIDEWALL > TIRES
dt*: the contact stated while driving on normal road conditions the tire wall became totally detroyed presenting slashes three inches
2
~ 9850 miles
AUTOMATIC (ASC) > ELECTRONIC STABILITY CONTROL
i purchased a brand new 2004 toyota corolla le from bob pagan/sand dollar toyota 7626 broadway galveston tx 77551 on...
2
~ 11500 miles
EQUIPMENT
on three occasions the vehicle would not start as a result of a drained battery. 1st time the dealer replaced...
2
~ 4750 miles
IGNITION > ELECTRICAL SYSTEM
my car on an intermittent basis will not start after turning the key in the ignition. there is no cranking...
2
~ 28000 miles
STRUCTURE
the frame along the windshield on the passenger's side obstructs vision causing the driver not to see well. the driver...
2
~ 40642 miles
ACCELERATOR PEDAL > VEHICLE SPEED CONTROL
consumer states that brake pedal was too close to the gas pedal. when the brakes were depressed the consumer's foot
2
~ 75000 miles
SUSPENSION
i heard a loud pop when driving at 25 mph then something started grinding all the way home. my husband...
1
~ 133083 miles
HORN > ELECTRICAL SYSTEM
tl* the contact owns a 2004 toyota corolla. the contact stated that while driving at 40 mph the vehicle would...
1
~ 150000 miles
DOOR > BODY > STRUCTURE
tl* the contact owns a 2004 toyota corolla. the contact stated that the driver side door failed to unlock. the...
1
INSTRUMENT CLUSTER/PANEL > ELECTRICAL SYSTEM
speedometer stopped at 299 999. *tr...
1
~ 299999 miles
COOLING SYSTEM > ENGINE AND ENGINE COOLING
my vehicle's air conditioner (2004 toyota corolla) is not working properly. the system will work for a few moments (blowing...
1
SERVICE BRAKES, AIR
i drive a 2004 toyota corolla and i have had many incidents of unintended acceleration. in every case it has...
1
REAR WINDOW WIPER/WASHER > VISIBILITY
tl. the contact owns a 2004 toyota corolla. the contact took the vehicle to the dealer to have a recall...
1
~ 80000 miles
BUCKLE ASSEMBLY > FRONT > SEAT BELTS
tl* the contact owns a 2004 toyota corolla. the contact stated that the rear passenger seat belt failed and would...
1
~ 85000 miles
SERVICE BRAKES, ELECTRIC
engine will surge when at a stop and unless brake is fully depressed to the floor vehicle may move forward....
1
~ 80000 miles
DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY
tl*the contact owns a 2004 toyota corolla. the contact stated that there was a foul odor coming from the climate...
1
~ 42000 miles
MARKINGS > TIRES
watched 20/20 may 9th 2008 about how to check for production date on tires. checked date on tires may 10th...
1
~ 36564 miles
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, GASOLINE
2004 toyota corolla with check engine light on. consumer states that the mechanic determined that one of the welds on
1
HOSE, PIPING, AND CONNECTIONS > HYDRAULIC POWER ASSIST > STEERING
the belt tensioner on this vehicle has failed for the second time. vehicle was purchased new and needed a new...
1
~ 78689 miles
SELECTOR DEVICES > AUXILLARY TANK > STORAGE
we bought a toyota corrola model 2004. since we bought it til now it always has a persistent problem with...
1
GAS RECIRCULATION VALVE (EGR VALVE) > EMISSION CONTROL > EXHAUST SYSTEM
i own a 2004 toyota corolla (45 000 miles) and the check engine light illuminated (read code p0456 emission control...
1
~ 45000 miles
HOSES, LINES/PIPING, AND FITTINGS > HYDRAULIC > POWER ASSIST
i have two claims on toyota corolla's. each vehicle had a fire start in the wheel well area. the dealer...
1
~ 24945 miles
REAR > SUSPENSION
dt*: the contact stated having problems with the vehicle's rear right axle while driving 55 mph. prior to the incident...
1
~ 35000 miles
WHEEL BEARING > FRONT > SUSPENSION
my car has been making a loud noise especially when driving over 40 mph. i took it to the dealership...
1
~ 40000 miles
HUB > WHEELS
my car has been making a loud noise especially when driving over 40 mph. i took it to the dealership...
1
~ 40000 miles
DELIVERY > FUEL SYSTEM, GASOLINE
when parking the car the car attempted to accelerate on its own. i looked down to make sure my foot...
1
~ 14800 miles
CRUISE CONTROL > VEHICLE SPEED CONTROL
my husband was driving my 2004 corolla-s. he had the cruise control set for 75 mph. i looked down at...
1
WINDSHIELD > VISIBILITY
windshield is very susceptable to cracks. original windshield was hit with a very small pebble while driving at relatively low...
1
~ 6000 miles
FOG LIGHTS > EXTERIOR LIGHTING
corolla s 2004 kit on bottom near fog lights seems to always peel off on both driver and passenger side...
1
~ 10443 miles
SIDE/WINDOW > AIR BAGS
2004 toyota corolla le with 13000 miles and equiped with front and side airbags. *akall four airbags did not deploy
1
~ 13000 miles
WIRING > ELECTRICAL SYSTEM
consumer's vehicle came to a stop at a red light when hearing three beeps coming from the car the car...
1
MID/REAR ASSEMBLY > SEATS
i bought a toyota corolla 2004 sedan from gordie boucher nissan 10606 w. arthur avenue west allis wisconsin phone no....
1
REAR/OTHER > SEAT BELTS
consumer was unable to unlock the rear passenger seat belt. consumer tried to unlock the seat belt numerous times but...
1
ELECTRICAL > EQUIPMENT
appears that the drl system mandated by dot can not be deactivated. all military installations madate that a vehicle's headlights...
1
RECLINER > FRONT ASSEMBLY > SEATS
while sitting in the rear seat with legs extended out the passengers foot was badly cut on a sharp instrument...
1
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, DIESEL
a crack in the fuel tank was causing the consumer to smell gas fumes while driving. dealership was notified but
1
~ 6000 miles
SHOCK ABSORBER > FRONT > SUSPENSION
i purchased a brand new 2004 toyota corolla le from bob pagan/sand dollar toyota 7626 broadway galveston tx 77551 on...
1
12V/24V/48V BATTERY > ELECTRICAL SYSTEM
on two separate occasions while trying to start the vehicle engine would not turn over. consumer felt that the problem
1
~ 50 miles
COLUMN > STEERING
dealer replaced the steering column mechanism but problem recurred. also while driving vehicle vibrated. *ak...
1
CONVENTIONAL > PARKING BRAKE
hand brake doesn't hold well. also when the hand brake is on and you or your passenger gets out of...
1
~ 500 miles
COIL SPRINGS > SPRINGS > REAR
hand brake doesn't hold well. also when the hand brake is on and you or your passenger gets out of...
1
~ 500 miles
REARVIEW MIRRORS/DEVICES > VISIBILITY
sun visor on driver side interferes with rear view mirror. when visor is pulled down it hits the rear view...
1
~ 100 miles
FUEL RAIL > FUEL INJECTION SYSTEM > FUEL SYSTEM, GASOLINE
i bought a 2004 toyota corolla in july of 2003 not even two months of having the car i am...
1
~ 1500 miles
SENSOR/CONTROL MODULE > FRONTAL > AIR BAGS
the air bag light appeared on the dashboard until the vehicle was turned off. the driver had taken the vehicle...
1
~ 2186 miles
INJECTORS > FUEL INJECTION SYSTEM > FUEL SYSTEM, GASOLINE
i bought a 2004 toyota corolla in july of 2003 not even two months of having the car i am...
1
~ 1500 miles
LUGS/NUTS/BOLTS > WHEELS
manufacturing date of vehicle posted on the nhtsa website is wrong. *la (nar) *cb ...
1

Torque wrench

  • EPAuto 1/2-inch Drive Click Torque Wrench, 10~150 ft./lb., 13.6 ~ 203.5 N/m

    EPAuto 1/2-inch Drive Click Torque Wrenc...

    • Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
    • Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
    • Easy to Read: High...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 10~150 Ft-Lb/13.6~203.5 Nm (LX-183)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
    • LONGEVITY -...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 25-250 Ft-Lb/33.9-338.9 Nm (LX-184)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON 3/8-Inch Drive Click Torque Wrench 10~80 Ft-Lb/13.6~108.5 Nm (LX-182)

    LEXIVON 3/8-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON Inch Pound Torque Wrench 1/4-Inch Drive | 20~200 in-lb/2.26~22.6 Nm (LX-181)

    LEXIVON Inch Pound Torque Wrench 1/4-Inc...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • TEKTON 3/8 Inch Drive Micrometer Torque Wrench (10-80 ft.-lb.) 24330

    TEKTON 3/8 Inch Drive Micrometer Torque ...

    • Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
    • Wrench emits a click that can be heard and felt when the preset value is reached
    • Permanently marked, high-contrast dual-range...

Mechanic tool set

  • Crescent 180 Pc. Professional Tool Set in Tool Storage Case - CTK180

    Crescent 180 Pc. Professional Tool Set i...

    • The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
    • Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
    • Get incredible access from combination wrenches with narrow heads,...
  • Craftsman Mechanic Tool Set, 215 Piece, Hand Box Set in Metal, 3 Drawers, Red (CMMT45303)

    Craftsman Mechanic Tool Set, 215 Piece, ...

    • MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
    • VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
  • Craftsman Mechanic Tool Set, 230 Piece with 3 Drawers, Sockets, Extension Bars, Wrenches, Hex Keys, and More (CMMT45305)

    Craftsman Mechanic Tool Set, 230 Piece w...

    • TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
    • OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
  • DEWALT Mechanics Tool Set, 1/4' & 3/8' & 1/2' Drive, SAE/Metric, 205-piece (DWMT81534)

    DEWALT Mechanics Tool Set, 1/4" & 3/8" &...

    • 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
    • Anti-slip driver handle provides maximum comfort
    • Housed in a durable carrying case with metal latches
    • Full-polish chrome for corrosion resistance
  • DEWALT Mechanics Tools Kit and Socket Set, 142-Piece, 1/4 & 3/8' Drive, MM/SAE (DWMT73802)

    DEWALT Mechanics Tools Kit and Socket Se...

    • Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
    • Ratchets include a low profile directional lever to help reduce catch points and for easy...
  • Amazon Basics Mechanic's Tool Set with Chrome Finish and Case - Set of 201 Pieces

    Amazon Basics Mechanic's Tool Set with C...

    • Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
    • Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
    • Both metric...

Tool box

  • TUFFIOM 8-Drawer Rolling Tool Chest w/Lock & Key, Tool Storage Cabinet w/Wheels, Detachable Top, Drawers, Side Hooks & Drawer Liners, Tool Organizer Box for Garage, Warehouse & Repair Shop, Red

    TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...

    • LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
  • beyond by BLACK+DECKER BLACK+DECKER BDST60500APB Stackable Storage System - 3 Piece Set (Small Toolbox, Deep Toolbox, and Rolling Tote)

    beyond by BLACK+DECKER BLACK+DECKER BDST...

    • Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
    • Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
  • BIG RED ANTBD133-XB Torin 20' Portable 3 Drawer Steel Tool Box with Metal Latch Closure, Red

    BIG RED ANTBD133-XB Torin 20" Portable 3...

    • Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
    • Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
  • DEKOPRO 228 Piece Socket Wrench Auto Repair Tool Combination Package Mixed Tool Set Hand Tool Kit with Plastic Toolbox Storage Case

    DEKOPRO 228 Piece Socket Wrench Auto Rep...

    • HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
    • COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
  • Torin 17-Inch Plastic Tool Box,3-Tiers Multi-Function Storage Portable Toolbox Organizer, Black/Orange ATRJH-3430T

    Torin 17-Inch Plastic Tool Box,3-Tiers M...

    • Tough metal latches are solid and easy to open and close, with long use life
    • Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
  • CARTMAN 148 Piece Automotive and Household Tool Set - Perfect for Car Enthusiasts and DIY Home Repairs

    CARTMAN 148 Piece Automotive and Househo...

    • Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
    • Durable and Corrosion-Resistant: All tools in the kit...


2004 Toyota Corolla specs
Compare

Exterior

Bulbs

Maintenance

Complaints

Forgive our ad-diction! It's just our funky little way of keeping the lights on. Bear with us!

Discussion