Major Problems with 2004 Mazda Mazda6 Derived from Complaints & Recalls
Custom-fit Add-ons
Worst 3 complaints of 2004 Mazda Mazda6
2004 Mazda Mazda6
SEAT BELTS
Victims: 7
2004 Mazda Mazda6
AIR BAGS
Victims: 2
2004 Mazda Mazda6
AIR BAGS
Victims: 2
Mileage: 180000 miles
Browse 2004 Mazda Mazda6 complaints by category
Problems with AIR BAGS, ELECTRICAL SYSTEM and POWER TRAIN are the most frequent issues recorded by the NHTSA from Mazda Mazda6 owners.
Problem Category | Number of Problems |
AIR BAGS on the 2004 mazda3 after about 3000 miles the main airbag light illuminates indicating a failure of some kind in... |
52
~ 12011 miles |
ELECTRICAL SYSTEM originally 5 months ago i noticed a problem with my 2004 mazda 6i at when stopped at a red light.... |
10
~ 209231 miles |
POWER TRAIN transmission problems....it wont reverse it's making scary noises and it's jerking none stop. mechanic said i have to get it... |
9
~ 92901 miles |
BODY > STRUCTURE 2004 mazda 6 with corrosion around the rear passenger side wheel well. reported to mazda north america operation on november... |
8
~ 104803 miles |
ENGINE AND ENGINE COOLING aug 27 engine noise aug 29 mazda diagnosed internal engine damage. 2004 19 000 miles under warranty-mazda wont repair says... |
7
~ 66075 miles |
VEHICLE SPEED CONTROL i was originally misquoted in my complaint taken over the phone so i am writing this as a clarification of... |
7
~ 51490 miles |
ENGINE the way the catalytic converter is designed on cylinders 1 3 and5 it gets clogged but buy than your rings... |
6
~ 66776 miles |
LATCHES/LOCKS/LINKAGES the driver's door on my 2004 mazda 6 will not open. this car has electric locks. all doors open except... |
6
~ 83682 miles |
AUTOMATIC TRANSMISSION > POWER TRAIN vehicle design problem that could easily result in fatality. 2004 mazda 6s. this is the transmission that can either be... |
6
~ 48008 miles |
SERVICE BRAKES, HYDRAULIC while pulling into a parking space the brakes disengaged almost causing consumer's vehicle to crash into other vehicles. the dealer... |
5
~ 41140 miles |
DOOR > BODY > STRUCTURE driver door stuck. *tr... |
4
~ 60000 miles |
TIRES goodyear eagle gt tire sidewall splitting/tearing. i purchased four new goodyear gt tires size 215/50r-17 from retailer discount tire in... |
4
~ 76026 miles |
FUEL SYSTEM, GASOLINE engine failed while driving because of a problem with the throttle body. there was no warning. found that mazda has... |
4
~ 53402 miles |
EXTERIOR LIGHTING tl*the contact owns a 2004 mazda 6. the contact stated that the exterior lighting fails to remain illuminated on the... |
4
~ 69725 miles |
LATCH > DOORS > LATCHES/LOCKS/LINKAGES car is a mazda 6 sport wagon 2004 with power door locks. this is not a complaint against a dealer... |
4
~ 38913 miles |
SEATS dt: air conditioner will fog up the windshield. it blows through the defroster and it blows moisture on the windshield.... |
4
~ 29464 miles |
UNKNOWN OR OTHER i sold this mazda6 to an auto dealer (shortline auto group aurora co) in november 2015. i have since received... |
3
~ 489464 miles |
SEAT BELTS tl* the contact stated that due to a crash the vehicle caught on fire at the base of the seat... |
3
~ 23626 miles |
STRUCTURE dt: consumer's vehicle has a handle above the door of the back seat. consumer's mother was holding onto handle when... |
3
~ 40000 miles |
STEERING car has slight pull to the right ever since it was purchased new from the dealer. various repairs have not... |
3
~ 79214 miles |
FRONT > SUSPENSION the vehicle did not drive straight. it constantly pulled to the right. the vehicle has been serviced 5 times in |
3
~ 40338 miles |
SIDEWALL > TIRES goodyear eagle gt tire sidewall splitting/tearing. i purchased four new goodyear gt tires size 215/50r-17 from retailer discount tire in... |
2
~ 47000 miles |
HEADLIGHTS > EXTERIOR LIGHTING i have been having trouble with the headlights and fog lights on my 2004 mazda 6s. i have had to... |
2
~ 47575 miles |
ROTOR > DISC > FOUNDATION COMPONENTS 2004 mazda6 this is what i sent to mazda and their reply: "33968 miles. second time the front rotors had... |
2
~ 25857 miles |
MANUAL TRANSMISSION > POWER TRAIN i have a 2004 mazda6 wagon with an automatic transmission. i have brought the car into a mazda dealership twice... |
2
~ 51500 miles |
DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY dt: air conditioner will fog up the windshield. it blows through the defroster and it blows moisture on the windshield.... |
2
~ 950 miles |
ENGINE > ENGINE AND ENGINE COOLING consumer requesting information to be included in mazda owners manual. that vehicle may cut out or lose power etc. while... |
2
~ 22500 miles |
THROTTLE > VEHICLE SPEED CONTROL repeated throttle body issues car while driving will drop to a crawl with erratic revving. did this in the middle... |
1
|
SUN/MOON ROOF ASSEMBLY > VISIBILITY driving down the road and the sunroof exploded. nothing hit the sunroof. heard a cracking sound and did not know... |
1
|
SERVICE BRAKES tl* the contact owns a 2004 mazda 6. when the emergency brake was applied the vehicle was able to roll... |
1
~ 103001 miles |
ELECTRONIC STABILITY CONTROL constant overheating problems. changed everything from hoses to radiator thermostat and gasket but it still comes on after a while.... |
1
~ 127643 miles |
VISIBILITY/WIPER obscured rear vision on sportwagons. replacements for original replaceable rear blade carrier do not correctly fit the original wiper arm... |
1
~ 34000 miles |
WHEELS mazda 6i hatchback developed severe pull to the right during regular city even driving on a flat surface. a strong... |
1
~ 110000 miles |
SUSPENSION transmission problems....it wont reverse it's making scary noises and it's jerking none stop. mechanic said i have to get it... |
1
|
TRACTION CONTROL SYSTEM may 25 2010 re: failure of traction control module: i have a 2004 mazda 6 wagon that i bought new... |
1
~ 32864 miles |
TREAD/BELT > TIRES continental tire extreme contact sidewall seperation w less than 100 miles. replacement tire had tread seperation within 24 hours. if |
1
~ 45000 miles |
EXHAUST SYSTEM > ENGINE AND ENGINE COOLING pre catalytic converter failed destroying my v6 engine. i thought it was a joke but i heard several cases with... |
1
~ 65000 miles |
CLUTCH ASSEMBLY > POWER TRAIN 1)nov. '04....12 hours after we purchased the vehicle were called back to have mazda replace gas tank "due to recall".mazda... |
1
~ 1500 miles |
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, GASOLINE 1)nov. '04....12 hours after we purchased the vehicle were called back to have mazda replace gas tank "due to recall".mazda... |
1
~ 1500 miles |
FUSES AND CIRCUIT BREAKERS > WIRING > ELECTRICAL SYSTEM i own a 2004 mazda 6 sports sedan which still has a factory warranty. my wife & i are having... |
1
~ 24688 miles |
FOG LIGHTS > EXTERIOR LIGHTING i have been having trouble with the headlights and fog lights on my 2004 mazda 6s. i have had to... |
1
~ 55150 miles |
SENSOR/CONTROL MODULE > FRONTAL > AIR BAGS i was in a front-impact collision going approximately 10 mph. the damage to my mazda 6 was very minimal to... |
1
|
COOLING SYSTEM > ENGINE AND ENGINE COOLING 2004 mazda 6 made a rattling sound in the front end. upon inspection mechanic determined the radiator had a hole... |
1
|
FAN/MOTOR > DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY problem #1 high ambient air temperature (80+) and medium to high humidity (50%+) when air conditioner is in manual mode... |
1
~ 1500 miles |
AIR CONDITIONER > APPLIANCE > EQUIPMENT dt: air conditioner will fog up the windshield. it blows through the defroster and it blows moisture on the windshield.... |
1
~ 400 miles |
IGNITION > ELECTRICAL SYSTEM dt*: the contact stated the vehicle intermittently will not start. the vehicle often starts if the key is turned to... |
1
~ 15000 miles |
PARKING BRAKE while parking on an incline i attempted to set the caras parking brake. with my foot on the brake pedal... |
1
~ 6500 miles |
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC while driving 45 mph the driver applied the brake pedal and the brakes lock. the driver applied the brake pedal |
1
|
FRONTAL > AIR BAGS while driving 45 mph the consumer crashed into the vehicle in front of him. the air bags failed to deploy |
1
|
HOSES, LINES/PIPING, AND FITTINGS > DELIVERY > FUEL SYSTEM, GASOLINE i have a 2004 mazda 6s i have had two incidents where the fuel line has detached from inside... |
1
~ 4256 miles |
LINES AND FITTINGS > LPG SYSTEMS > RECREATIONAL VEHICLE/TRAILER i have a 2004 mazda 6s i have had two incidents where the fuel line has detached from inside... |
1
~ 4256 miles |
REAR WINDOW > DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY rear windshield defroster system shorted out causing the rear windshield to shatter. the rear seat was occupied at the time... |
1
~ 2700 miles |
Torque wrench
-
EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...
Mechanic tool set
-
Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
-
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
-
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
-
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
-
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
-
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...
Tool box
-
TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
-
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
-
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
-
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
-
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
-
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...
Discussion