Major Problems with 2004 GMC Sierra 1500 Derived from Complaints & Recalls
Custom-fit Add-ons
Worst 3 complaints of 2004 GMC Sierra 1500
2004 GMC Sierra 1500
SERVICE BRAKES, HYDRAULIC
Victims: 2
Mileage: 56000 miles
2004 GMC Sierra 1500
SERVICE BRAKES
Victims: 2
Mileage: 37000 miles
2004 GMC Sierra 1500
AIR BAGS
Victims: 1
Mileage: 36000 miles
Browse 2004 GMC Sierra 1500 complaints by category
Problems with INSTRUMENT CLUSTER/PANEL, SERVICE BRAKES and ELECTRICAL SYSTEM are the most frequent issues recorded by the NHTSA from GMC Sierra 1500 owners.
Problem Category | Number of Problems |
INSTRUMENT CLUSTER/PANEL > ELECTRICAL SYSTEM speedometer displays erroneous readings never correct. *nm... |
47
~ 49225 miles |
SERVICE BRAKES tl* the contact owns a 2004 gmc sierra 1500. the contact stated that the brake lines were deteriorating and the... |
42
~ 108647 miles |
ELECTRICAL SYSTEM my speedometer on my 2004 gmc z71 works erratically. sometimes it will peg out at 120 or it sticks at... |
31
~ 63313 miles |
STEERING power steering faded at high speed. this was caused by the steering rotation sensor. consumer had to put pressure on... |
17
~ 44203 miles |
SERVICE BRAKES, HYDRAULIC while driving consumer applied the brakes and pedal went to the floor. vehicle hit a meridian strip pole. consumer was... |
16
~ 51752 miles |
VEHICLE SPEED CONTROL dt*: the contact stated while driving 75 mph on the interstate the speedometer gauge began to decrease and increase without... |
8
~ 22966 miles |
TIRES i purchased a new 2004 gmc in febuary 04 and it keeps wearing the front tires to excess and the... |
6
~ 30983 miles |
ENGINE exhaust manifold bolts broke off causing the drivers side heat shield to fall and jam under the steering linkage. this... |
5
~ 85779 miles |
FUEL/PROPULSION SYSTEM regardless of type of road i.e. highway or city roads and regardless of speed the vehicle will stall and shut |
4
~ 109215 miles |
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC i was traveling at 35 mph on a city street and had to stop quickly. i applied the brakes and... |
4
~ 22771 miles |
AIR BAGS while driving consumer applied the brakes and pedal went to the floor. vehicle hit a meridian strip pole. consumer was... |
4
~ 105667 miles |
POWER TRAIN since the purchase of my vehicle there have been multiple issues with the vehicle 7-8 issues one selling point was... |
4
~ 59266 miles |
ENGINE AND ENGINE COOLING i hear a tapping of the valves when the car is on. also the speedometer will stop registering how fast |
3
~ 55840 miles |
WHEELS i purchased bridgestone dueler alenza hl tires at 42509 on 06/10/2009 and on 04/10/2011 i had a slow leak and... |
3
~ 102869 miles |
ENGINE > ENGINE AND ENGINE COOLING reduced engine power this has happened about 7 times. when this happens the engine shuts down to 1500 rpms maximum.... |
3
~ 44322 miles |
COLUMN > STEERING i have a 2004 gmc sierra ext. cab truck with about 70k miles on it. in the past week the... |
3
~ 34126 miles |
AUTOMATIC TRANSMISSION > POWER TRAIN dt*: the contact stated while traveling 20 mph the transmission made a noise while it was changing gears. at first... |
3
~ 6354 miles |
SUSPENSION frame rust. *ln... |
2
~ 68000 miles |
EXTERIOR LIGHTING when the weather is below freezing the turn signals do not work until the vehicle has warmed up for atleast... |
2
~ 121000 miles |
ELECTRONIC STABILITY CONTROL instrument cluster works intermittently. speedometer fuel gauge etc do not work at random times. (while operating the vehicle or not)... |
2
~ 44250 miles |
COOLING SYSTEM > ENGINE AND ENGINE COOLING i also had to have the actuator replaced on my gmc 2004 truck. it was blowing hot when the a/c... |
2
~ 23991 miles |
PARKING BRAKE vehicle had less than 20 000 miles when right rear brake disc wore completely out. had to replace again at... |
2
~ 42000 miles |
FUEL SYSTEM, OTHER internal failure of part in fuel tank that caused the fuel gauge to not read accurately but allowed the low... |
2
~ 68250 miles |
HOSES, LINES/PIPING, AND FITTINGS > FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC dt*: the contact stated while driving at an unknown speed the brakes were applied and failed. when the brake pedal... |
2
~ 49000 miles |
CRUISE CONTROL > VEHICLE SPEED CONTROL cruise control does not work properly when descending down a hill the truck picks up speed there is no hold |
2
~ 2600 miles |
ELECTRICAL > EQUIPMENT since the purchase of my vehicle there have been multiple issues with the vehicle 7-8 issues one selling point was... |
2
~ 6000 miles |
FUEL GAUGE SYSTEM > STORAGE > FUEL SYSTEM, OTHER tl* the contact owns a 2004 gmc sierra 1500. while operating the vehicle the engine suddenly stalled. it was discovered... |
1
~ 160000 miles |
FUEL SYSTEM, GASOLINE fuel tank has rusted steel support straps rear strap broke and tank dropped a few inches placing additional pressure on... |
1
~ 92405 miles |
AIR CONDITIONER > APPLIANCE > EQUIPMENT in my 2004 gmc sierra the wiring harness for the a/c down near the passenger floorboard smokes and i smell... |
1
~ 60000 miles |
FRONTAL > AIR BAGS air bag sensor icon stays on showing a problem with the front passenger airbag. don't know what that means other... |
1
~ 51525 miles |
TRANSFER CASE (4-WHEEL DRIVE) > POWER TRAIN tl* the contact owns a 2004 gmc sierra. the contact was towing a boat and discovered there was transfer case... |
1
~ 82000 miles |
EQUIPMENT tire separation. *tr... |
1
~ 25000 miles |
TREAD/BELT > TIRES tire separation. *tr... |
1
~ 25000 miles |
VISIBILITY 2004 gmc sierra crew cab - burning odor soot on dashboard rear windows fail to operate. no blown fuses. taken... |
1
~ 57384 miles |
SERVICE BRAKES, ELECTRIC i own a 2004 gmc sierra 1500 z71 with 32 000 on the odometer. on the morning of 27aug2008 the... |
1
~ 32000 miles |
REAR WINDOW WIPER/WASHER > VISIBILITY windshield wipers stopped working while in the interm. position. then they stayed on all the time even with the switch |
1
~ 53000 miles |
DIFFERENTIAL UNIT > DRIVELINE > POWER TRAIN 2004 gmc sierra sle w/trailer towing package 2-wheel drive. 2nd owner. never used to tow whatsoever. extremely well cared for.... |
1
~ 59600 miles |
SEAT BELTS own a 2004 gmc sierra bought brand new had numerous problems steering gear box went out completely dealer r/r part... |
1
~ 30 miles |
RECREATIONAL VEHICLE/TRAILER > EQUIPMENT own a 2004 gmc sierra bought brand new had numerous problems steering gear box went out completely dealer r/r part... |
1
~ 30 miles |
MECHANICAL > EQUIPMENT reduced engine power this has happened about 7 times. when this happens the engine shuts down to 1500 rpms maximum.... |
1
~ 41600 miles |
PADS > DISC > FOUNDATION COMPONENTS vehicle had less than 20 000 miles when right rear brake disc wore completely out. had to replace again at... |
1
~ 20000 miles |
SWITCH/WIRING > WINDSHIELD WIPER/WASHER > VISIBILITY 1 speedometer registering 120 sitting still ( replaced cluster). 2 wipers would not shut off ( replaced wiper motor circuit |
1
~ 17377 miles |
FLASHER UNIT > TURN SIGNAL > EXTERIOR LIGHTING my 2004 gmc sierra would light all four turn signals when the left turn signal was applied as if the... |
1
~ 45760 miles |
UNIT > HAZARD FLASHING WARNING LIGHTS > EXTERIOR LIGHTING my 2004 gmc sierra would light all four turn signals when the left turn signal was applied as if the... |
1
~ 45760 miles |
DISC > FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC on or about 12/01/06 while pulling my truck ahead the brakes failed causing me to roll into a parked vehicle.... |
1
~ 5 miles |
IGNITION > ELECTRICAL SYSTEM dt*: the contact stated while driving various speeds the engine stalled without warning and would not restart. the vehicle was... |
1
~ 36415 miles |
SHAFT SECTOR > GEAR BOX > STEERING i have a 2004 z71 sierra truck with a 5.3 engine that has a speedometer problem. it reads 120mph all... |
1
~ 47000 miles |
FRONT > SUSPENSION 7-11-2005 replaced intermediate shaft at 13620 miles 9-26-2007 52271 replaced intermediate shaft 59639 replaced right inner tie rod and rack-rack... |
1
~ 13620 miles |
U-BOLT, LEAF SPRING TO AXLE > LEAF SPRING ASSEMBLY > SPRINGS the leaf springs continuously squeak...and are way too noisy! i have personally tried to clamp them down...grease them..so they do |
1
~ 31 miles |
ACCELERATOR PEDAL > VEHICLE SPEED CONTROL while driving 20 mph vehicle stalled .consumer applied the accelerator pedal and the vehicle failed to accelerate. vehicle was taken... |
1
|
CABLES > 12V/24V/48V BATTERY > ELECTRICAL SYSTEM upon entering the vehicle there was no power. aaa was called and it would not take a jump. the dealer... |
1
~ 1000 miles |
Torque wrench
-
EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...
Mechanic tool set
-
Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
-
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
-
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
-
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
-
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
-
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...
Tool box
-
TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
-
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
-
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
-
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
-
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
-
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...
Discussion