Major Problems with 2004 GMC Envoy XUV Derived from Complaints & Recalls

Custom-fit Add-ons

Torque wrench
Mechanic tool set
Tool box

Worst 3 complaints of 2004 GMC Envoy XUV

2004 GMC Envoy XUV ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP Victims: 1

2004 GMC Envoy XUV AIR BAGS Victims: 1

2004 GMC Envoy XUV LATCHES/LOCKS/LINKAGES Victims: 1 Mileage: 22500 miles

Browse 2004 GMC Envoy XUV complaints by category

Problems with ELECTRICAL SYSTEM, INSTRUMENT CLUSTER/PANEL, FUEL SYSTEM and GASOLINE are the most frequent issues recorded by the NHTSA from GMC Envoy XUV owners.

Problem Category	Number of Problems
ELECTRICAL SYSTEM 2004 gmc envoy xuv i have a little over 40 000 miles and my speedometer has stopped working. it says...	46 ~ 62380 miles
INSTRUMENT CLUSTER/PANEL > ELECTRICAL SYSTEM driving on the highway apx 70 mph. speedometer was indications 110 mph. pulled over and speedometer still indicated 35 mph	32 ~ 46367 miles
FUEL SYSTEM, GASOLINE tl*the contact owns a 2004 gmc envoy xuv. on september 3 2007 the check engine light illuminated and the contact...	17 ~ 71325 miles
AIR BAGS vehicle: n04 gmc envoy vin: [xxx] the above vehicle was purchased 12/31/04 and was totaled 5/05. my son was driving...	9 ~ 74825 miles
FUEL/PROPULSION SYSTEM when in traffic traveling across states on highway at 55-65 mph left lane(scary) i ran out of gas when the...	8 ~ 112306 miles
VEHICLE SPEED CONTROL 2004 gmc envoy speedometer slows down to zero at highway speeds. *jb...	8 ~ 71073 miles
LATCHES/LOCKS/LINKAGES while sitting in a drive through window at a restaurant with the vehicle in drive two men entered the rear...	7 ~ 37357 miles
ENGINE exhaust manifold cracked. gm has a special extended warrenty on model years 2008-2009 only. yet they are the same manifold...	5 ~ 94370 miles
EXTERIOR LIGHTING my speedometer has stopped working. the gas gauge says empty when i have just fueled the car to full. the...	5 ~ 103653 miles
VISIBILITY about a year ago my back window would sometimes just go down. after about a month the window motor started...	4 ~ 55938 miles
POWER WINDOW DEVICES AND CONTROLS > VISIBILITY on 3 separate occasions sun roof stuck in an open position. dealership replaced the sun roof motor. this provided a...	4 ~ 48450 miles
FUEL SYSTEM, OTHER took vehicle in for inspection and check engine soon light was on. a code p0455 was found which means a...	3 ~ 66041 miles
BODY > STRUCTURE tl* - the contact owns a 2004 gmc envoy xuv. the contact stated that the plastic trim molding on the...	3 ~ 55333 miles
UNKNOWN OR OTHER i purchased a new 2004 envoy xuv from rally gmc in palmdale ca (purchased in january 2004). at about 74000...	3 ~ 56250 miles
GLASS, SIDE/REAR > VISIBILITY while traveling on interstate 90 at 75 miles per hour the rear tailgate glass implode into the passenger compartment for...	3 ~ 9497 miles
POWER TRAIN shifter cable bushing became disengaged from the transmission. shifter lever floated freely through gears. when engine stopped it would not...	2 ~ 91070 miles
COOLING SYSTEM > ENGINE AND ENGINE COOLING i have a 2004 suv xlt. i bought my car with 400 miles on it. i had the gas tank...	2 ~ 42850 miles
TAILGATE > BODY > STRUCTURE end gate would not swing open. glass lowers. endgate opens flat. emergency button does not work either. since you can...	2 ~ 62500 miles
ENGINE AND ENGINE COOLING i purchased a 2004 gmc envoy xuv preowned in 2005 still under warranty. it began dimming the lights in the...	2 ~ 33600 miles
AUTOMATIC TRANSMISSION > POWER TRAIN traveling on the interstate at 60 mph transmission shifted gears via cruise control and the transmission lost 3rd and 4th	2 ~ 66393 miles
HINGE AND ATTACHMENTS > TAILGATE > BODY dt: the tailgate interlock failed. the tailgate could have fallen off. it was dangling on 1 hinge. ak sb *ak...	2 ~ 8500 miles
HEADLIGHTS > EXTERIOR LIGHTING tl* the contact owns a 2004 gmc enclave xuv. the contact stated that while driving about 55 mph the...	1 ~ 186000 miles
HATCHBACK/LIFTGATE > BODY > STRUCTURE tl* the contact owns a 2004 gmc envoy xuv. while attempting to utilize the liftgate it failed to operate. the...	1
ELECTRONIC STABILITY CONTROL i was driving down the road from work all of a sudden my radio starts going up /down by itself...	1 ~ 168440 miles
SEATS on june 8 2013 both the driver and passenger seat power adjustments ceased to operate or respond in any way....	1 ~ 102000 miles
PUMP > HYDRAULIC POWER ASSIST > STEERING tl*the contact owns a 2004 gmc envoy xuv. while driving 35 mph the power steering pump failed causing the vehicle...	1 ~ 80900 miles
REAR WINDOW WIPER/WASHER > VISIBILITY i purchased a 2004 gmc envoy xuv and have several significant problems with this vehicle. after researching it seem others...	1 ~ 45700 miles
SUSPENSION i have a 2004 suv xlt. i bought my car with 400 miles on it. i had the gas tank...	1 ~ 40000 miles
EXHAUST SYSTEM > ENGINE AND ENGINE COOLING i have a 2004 envoy xuv with a cracked exhaust manifold. my mechanic said he has seen a lot...	1 ~ 78000 miles
INTERIOR LIGHTING my speedometer has stopped working. the gas gauge says empty when i have just fueled the car to full. the...	1 ~ 90000 miles
EQUIPMENT we have a 2004 gmc envoy xuv which we purchase brand new in 2004. since last year winter i noticed...	1 ~ 72000 miles
MANUAL TRANSMISSION > POWER TRAIN the gears in the front differential got damaged at 41 000 miles. had to replace the gears. *tr...	1 ~ 41000 miles
STEERING bought new and loved the ride.list price was over $42 000. well maintained. 1st lost speedometer and other gauges. replaced...	1 ~ 36350 miles
WIRING > ELECTRICAL SYSTEM gmc dealer service tech found the wire to rear defroster corroded and broken. repaired wiring. *tr...	1 ~ 53500 miles
REAR WINDOW > DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY gmc dealer service tech found the wire to rear defroster corroded and broken. repaired wiring. *tr...	1 ~ 53500 miles
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, GASOLINE tl*the contact owns a 2004 gmc envoy xuv. on september 3 2007 the check engine light illuminated and the contact...	1 ~ 45100 miles
MOUNTING > TANK ASSEMBLY > STORAGE tl* the contact owns a 2004 gmc envoy. the vehicle was purchased on september 29 2004 and the mileage was...	1 ~ 38200 miles
FRONTAL > AIR BAGS my fiance was driving my 2004 gmc envoy suv. while driving reported to be approximately 40 mph the car in...	1
SERVICE BRAKES, HYDRAULIC my 2004 gmc envoy xuv had at least 12 failures to stop. this issue began occurring as soon as i...	1 ~ 700 miles
DEFROSTER/DEFOGGER/HVAC SYSTEM > VISIBILITY closed rear door on back of 2004 gmc envoy xuv and then started to drive the car. put on the	1 ~ 21890 miles
RETRACTOR > FRONT > SEAT BELTS 2004 envoy driver side seat belt will not release. *ts the consumer had great difficulty trying to get the seat	1
SWITCH > IGNITION > ELECTRICAL SYSTEM we bought new a 2004 gmc xuv. from the beginning we had problems with the ignition switch. the car would...	1 ~ 20000 miles
CARRIER/RACK > MECHANICAL > EQUIPMENT the consumers roof rack on the vehicle blew off while driving. the roof rack was hanging on the vehicle the...	1 ~ 3800 miles
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC vehicle: n04 gmc envoy vin: [xxx] the above vehicle was purchased 12/31/04 and was totaled 5/05. my son was driving...	1
MECHANICAL > EQUIPMENT what is happening to claim 10134972? *jb...	1
FRONT > SUSPENSION dt: the contact owns a 2004 gmc envoy. the contact states that the dealership had to replace the front sway...	1 ~ 24712 miles
AUTOMATIC (ASC) > ELECTRONIC STABILITY CONTROL i purchased a "new" 2004 gmc envoy the vehicle is approximateyl 11/2 to 21/2 inches higher on th left side....	1
LATCH > DOORS > LATCHES/LOCKS/LINKAGES i washed my envoy at a car wash by hand i wanted to see if the sells man was right...	1 ~ 500 miles
SUN/MOON ROOF ASSEMBLY > VISIBILITY on 3 separate occasions sun roof stuck in an open position. dealership replaced the sun roof motor. this provided a...	1 ~ 6000 miles
ENGINE > ENGINE AND ENGINE COOLING my envoy xuv (8cyl) has engine trouble which gmc says is normal. it occasionally has extremely rough idle more times...	1 ~ 40 miles

Torque wrench

EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...

Mechanic tool set

Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...

Tool box

TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...