Major Problems with 2000 Ford Excursion Derived from Complaints & Recalls
Custom-fit Add-ons
Worst 3 complaints of 2000 Ford Excursion
2000 Ford Excursion
TREAD/BELT
Victims: 8
2000 Ford Excursion
SUSPENSION
Victims: 7
2000 Ford Excursion
TIRES
Victims: 5
Mileage: 37000 miles
Browse 2000 Ford Excursion complaints by category
Problems with TIRES, TREAD/BELT and ELECTRICAL SYSTEM are the most frequent issues recorded by the NHTSA from Ford Excursion owners.
Problem Category | Number of Problems |
TIRES all four firestone tires failed (firestone steeltex a/t lt265/75r16-119/116-l.r.dm/s). nlm... |
96
~ 20337 miles |
TREAD/BELT > TIRES firestone tires experienced tread separation while driving (attorney for client). nlm... |
61
~ 4762 miles |
ELECTRICAL SYSTEM consumer is having electrical problems. there are a few items that don't even work at times like dome light and |
40
~ 76165 miles |
SIDEWALL > TIRES firestone tire exhibited sidewall tears in the area where the white letters were placed consumer has been told that the... |
36
~ 8950 miles |
ENGINE AND ENGINE COOLING while driving 45 mph vehicle stalled. this caused the driver to drift to side of the road. consumer had the... |
29
~ 98787 miles |
ROTOR > DISC > FOUNDATION COMPONENTS concerned about rotors needing to be replaced at 38 30 miles and brakes have been replaced also i am concerned |
21
~ 20429 miles |
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC complete brake failure upon approaching intersection. excursion was towed to nearest ford dealer where upon exam it was found that |
21
~ 3905 miles |
CRUISE CONTROL > VEHICLE SPEED CONTROL vehicle was parked in the garage which was attached to the home and without warning the vehicle burned. it was... |
17
~ 124503 miles |
ENGINE > ENGINE AND ENGINE COOLING while driving and when making a right or a left hand turn consumer has noticed a very loud knocking noise... |
15
~ 82898 miles |
SUSPENSION poor design causes vehicle to experience serious shaking/vibrating while driving at speeds over 55 mph. nlm... |
14
~ 13286 miles |
SWITCH > HEADLIGHTS > EXTERIOR LIGHTING while turning on headlights switch broke off. contacted dealer and dealer stated vehicle was not on recall.*ak... |
12
~ 71708 miles |
FRONT > SUSPENSION the design of the front suspension with a solid front axle is not sufficient for the vehicle steering stability and |
11
|
STEERING consumers daughter had stopped for gas when the attendant called attention to the fact that the tire was coming apart. |
10
~ 69800 miles |
VEHICLE SPEED CONTROL vehicle was parked consumer was in process of getting into vehicle and it popped out of gear and lurched backward. |
10
~ 70188 miles |
UNKNOWN OR OTHER dealer claims that ford does not have a fix for this failure. no safety defect listed in summary. *ak... |
10
~ 61319 miles |
AUTOMATIC TRANSMISSION > POWER TRAIN the consumer stated that the vehicle would not go into reverse or park after driving in snow due to snow |
9
~ 43333 miles |
FRONTAL > AIR BAGS we were run off the road on i-70 traveling through moab utah when our excursion smashed head on into the... |
9
~ 38368 miles |
ENGINE how can a company as ford claim to be an honest american car company...they should be stripped of their title... |
8
~ 95125 miles |
LATCHES/LOCKS/LINKAGES i have a 2000 ford excursion and all my door locks do not work. it tries to lock and unlock... |
8
~ 48875 miles |
GASOLINE > ENGINE > ENGINE AND ENGINE COOLING since ownership vehicle has experienced intermittent stalling problems vehilce has been taken in for service numerous occassions without being repaired... |
8
~ 29994 miles |
DISC > FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC after 10 000 miles brakes violently pulsate when braking and almost losing control of vehicle at highway speeds. i have... |
8
~ 7438 miles |
FRONT UNDERHOOD > WIRING > ELECTRICAL SYSTEM the wiring harness on the steering column causes the truck to stall when driver used the "tilt" option. the dealership |
8
~ 84106 miles |
DIESEL > ENGINE > ENGINE AND ENGINE COOLING on 2/25/06 my wife was at work and called due to our 2000 ford excursion not starting. i then went... |
7
~ 73902 miles |
MOTOR > WINDSHIELD WIPER/WASHER > VISIBILITY i own a 2000 ford excursion that recently experienced the exact symptoms described in a recall issued by ford on... |
7
~ 60579 miles |
AIR BAGS passenger side airbag warning light stays on. when i brought the vehicle to be repaired at the dealer i was... |
7
~ 78650 miles |
FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC on several occasions vehicle pulls slightly at slower speeds 15-40 mph and violently at speeds above 55 mph the pulling... |
6
~ 4000 miles |
SEATS middle seat after laying down to carry cargo will not lock into place and seat slams into back of front |
6
~ 144833 miles |
SERVICE BRAKES, HYDRAULIC while braking vehicle vibrates and shudders. *mr *nlm *dimsii ivoq entry posted after 12/12/02 cut -over to artemis**738752... |
6
~ 42805 miles |
LATCH > DOORS > LATCHES/LOCKS/LINKAGES as a result of a tire blowout consumer ran into a wall and passenger's doors opened upon impact. manufacturer was |
6
~ 20833 miles |
DOOR > BODY > STRUCTURE owner inadvertently closed the rear tri-doors on the vehicle in the wrong order which resulted in explosion of rear window |
5
~ 20200 miles |
IGNITION > ELECTRICAL SYSTEM consumer heard about a recall regarding stalling due to a faulty ignition system consumer states that her vehicle has stalled |
5
~ 26200 miles |
WIRING > ELECTRICAL SYSTEM v-10 spark plug blow out. *jb ... |
4
~ 43750 miles |
STRUCTURE while servicing the winshield washer fluid resevoir i noticed an area of rust located on the right side of the... |
4
~ 10000 miles |
EXTERIOR LIGHTING headlight switch feel off- i see ford was to notify customers in 2006 about this problem and they did not |
3
~ 112000 miles |
BEAD > TIRES consumer states tire bubbled up under the tread causing a blowout. dealer notified. *ak... |
3
~ 80667 miles |
FRAME AND MEMBERS > STRUCTURE this vehicle shakes rattles and rolls constantly alignment 3 seperate times extremely hard too stop nothing but problems with frame... |
3
|
SEAT HEATER/COOLER > FRONT ASSEMBLY > SEATS i own a 2000 ford excursion and have had problems with the rotors warping since new. the dealers have said... |
3
~ 35000 miles |
SERVICE BRAKES it's happened be for but never so scary. we were coming down one of the mountains on highway 299. we... |
2
~ 67094 miles |
VISIBILITY my 2000 excursion was parked in the yard and we had just unloaded groceries. the 2 bottom doors were closed... |
2
~ 151172 miles |
WHEELS tl*the contact owns a 2000 ford excursion. while driving 45 mph the contact noticed that the wheels were losing air.... |
2
~ 62000 miles |
MECHANICAL > CONVENTIONAL > PARKING BRAKE park brake assembly split in 2 complete failure of park brake and unit failure. whole unit must be replaced hardly |
2
|
REAR WINDOW WIPER/WASHER > VISIBILITY the rear windshield wiper does not operate due to the spring. also the brakes do not function properly due to |
2
~ 40000 miles |
LOWER BALL JOINT > CONTROL ARM > FRONT ball joint failure on 2000 ford excursion. the vehicle has 67000 miles with no towing or severe use. ford has |
2
~ 37000 miles |
UPPER BALL JOINT > CONTROL ARM > FRONT ball joint failure on 2000 ford excursion. the vehicle has 67000 miles with no towing or severe use. ford has |
2
~ 37000 miles |
BODY > STRUCTURE i purchased my 2000 ford excurion in summer 2003. the interior lights have been repaired several times times for staying... |
2
|
HEADLIGHTS > EXTERIOR LIGHTING nob used to turn on and off headlights broke off in consumer's hand. consumer can't grip nob to turn lights... |
2
|
GLASS, SIDE/REAR > VISIBILITY vehicle has three back doors. top one made of glass and two bottom ones. bottom one has to be closed... |
2
|
POWER TRAIN truck loses power attempted to restart restart went a few blocks and cut off again... |
2
~ 62500 miles |
DRIVESHAFT > DRIVELINE > POWER TRAIN vehicle had audible noise and vibration driveshaft was removed from 2001 model on lot and placed in my vehicle driveshaft... |
2
|
TIE ROD ASSEMBLY > LINKAGES > STEERING while backing out of the driveway the front right tie rod came "un-bolted" hit the ground. the right wheel assembly... |
2
|
VALVE > TIRES valve stem of spare tire exploded and caused tire to go flat 2 young children in back of vehicle were... |
2
|
WHEEL BEARING > FRONT > SUSPENSION while driving and when making a right or a left hand turn consumer has noticed a very loud knocking noise... |
2
~ 5000 miles |
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, GASOLINE the tire failure was a blowout. the whole sidewall shredded. firestone said it was a road hazard even though we... |
2
|
COIL SPRINGS > SPRINGS > FRONT the tire failure was a blowout. the whole sidewall shredded. firestone said it was a road hazard even though we... |
2
|
HYDRAULIC POWER ASSIST SYSTEM > STEERING since this vehicle was new it is often impossible to steer if you are stepping on the brakes at the... |
2
|
ACCESSORY SCISSOR/SCREW/BOTTLE JACK/LIFT > MECHANICAL > EQUIPMENT tire jack of insuffcient capacity to handle load. vehicle fell off three times while trying to change tire.*ak... |
2
|
REAR > SUSPENSION defect in suspension system of car causes the car to move laterally on dry pavement as if the car were... |
2
|
HEAD RESTRAINT > FRONT ASSEMBLY > SEATS headrests are not available for any of the 3rd seat benches. this could cause spinal injuries in a crash especially |
2
|
AXLE ASSEMBLY > POWER TRAIN 2000 ford excursion unit 1 was driving eastbound on the ohio turnpike in the middle lane when the left front... |
1
|
SEAT BELTS tl* the contact owns a 2000 ford excursion. while driving 50 mph she experienced a frontal vehicle crash. the vehicle... |
1
~ 187000 miles |
DRIVELINE > POWER TRAIN front manual hubs on 2000 ford 4wd. excursion seem to break apart frequently. u joints on front end makes noise |
1
~ 65000 miles |
FUEL SYSTEM, DIESEL 1999-2003 diesel ford excursion and all f series with 7.3ltr turbo diesel.. massive fuel leaks common . passenger side high... |
1
~ 130000 miles |
MANIFOLD/HEADER/MUFFLER/TAIL PIPE > EXHAUST SYSTEM > ENGINE AND ENGINE COOLING i own a 2000 ford excursion with a v10. while driving home from my son's track meet in a construction... |
1
|
DELIVERY > FUEL SYSTEM, GASOLINE i had been out of town when my 2000 ford excursion had a door ajar dummy light fail to shut... |
1
~ 81300 miles |
SWITCH/WIRING > WINDSHIELD WIPER/WASHER > VISIBILITY wife driving children to school wipers unknowingly frozen to window and wipers unknowingly on intermittent cycle wipers finally unfrozen and... |
1
~ 120600 miles |
LINKAGES > WINDSHIELD WIPER/WASHER > VISIBILITY wife driving children to school wipers unknowingly frozen to window and wipers unknowingly on intermittent cycle wipers finally unfrozen and... |
1
~ 120600 miles |
FUEL SYSTEM, GASOLINE dt: contact states vehicle had sporadic surging. the vehicle tended to surge at lower speeds. in may 2005 a mechanic... |
1
|
REAR/OTHER > SEAT BELTS 2000-2005 ford excursion manufactured with no center position shoulder harness or 3rd seat head restraint. ford should offer retrofit kit |
1
|
CHILD SEAT when the consumer lifted the shield to remove the child one side of the shields arm dislodged. *ak *sc *jb... |
1
|
LATCH > TAILGATE > LATCHES/LOCKS/LINKAGES i am the owner of a 2000 ford excursion (diesel). since owning the vehicle i have had a continuous problem... |
1
~ 56000 miles |
ELECTRICAL > EQUIPMENT i have a 2000 ford excursion. reference nhtsa campaign id number 01v258000:motor. i have called my ford dealer about this... |
1
|
EXTERNAL > WARNINGS > BACK OVER PREVENTION i purchased my 2000 ford excurion in summer 2003. the interior lights have been repaired several times times for staying... |
1
|
AXLE SHAFT > AXLE ASSEMBLY > POWER TRAIN this is a 2000 ford excursion limited 4x4 v-10. the truck has 38 000 miles and is well maintained. there... |
1
~ 38500 miles |
HOSES, LINES/PIPING, AND FITTINGS > DELIVERY > FUEL SYSTEM, GASOLINE a rat or a squirrel chewed up the fuel line causing fuel to leak. dealer notified. *ak the fuel line |
1
~ 20513 miles |
ABS WARNING LIGHT > ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC while applying the brake pedal vehicle failed to respond . also brake light appeared on the dashboard without prior warning. |
1
|
HANGER,BRACKET > LEAF SPRING ASSEMBLY > SPRINGS both spring of suspension bottomed out causing the vehicle to swerve without prior warning. *ak... |
1
|
PADS > DISC > FOUNDATION COMPONENTS when applied the brake at any speed vehicle vibrate. dealer notified. please provide further information.... |
1
|
ANTILOCK > SERVICE BRAKES, AIR when applied the brake at any speed vehicle vibrate. dealer notified. please provide further information.... |
1
|
LINKAGES > VEHICLE SPEED CONTROL consumer states while at a stop and foot on the brake the vehicle surged forward and the vehicle idols very |
1
|
FILLER PIPE AND CAP > TANK ASSEMBLY > STORAGE plastic assembly breaks when using standard diesel fill nozzle. when it is broken there is no seal for the cap... |
1
|
PARK/NEUTRAL START INTERLOCK SWITCH > AUTOMATIC TRANSMISSION > POWER TRAIN vehicle jumped from park to reverse without brake pedal being depressed. damage was caused to front porch of consumer's home.... |
1
|
ACCELERATOR PEDAL > VEHICLE SPEED CONTROL my foot became stuck between the brake pedal and the accelerator because it was dark and there was no lighting |
1
|
FUSES AND CIRCUIT BREAKERS > WIRING > ELECTRICAL SYSTEM 1st failure: pulling out of my driveway and noticed that my security system "theft" light was blinking. this shouldn't be... |
1
|
WINDSHIELD > VISIBILITY windshield cracked when sprayed with cold water while washing vehicle when new windshield was installed installer said he had seen... |
1
|
INTERIOR LIGHTING consumer is having electrical problems. there are a few items that don't even work at times like dome light and |
1
|
SHAFT SECTOR > GEAR BOX > STEERING ea 01 009 manual: shaft sector broke while driving at 25 mph and caused a loss of steering control. dealer |
1
|
STEERING WHEEL/HANDLE BAR > STEERING when attempting to turn vehicle it cannot be turned while brakes are on. dealership is aware of problem. *ak... |
1
|
ANCHORAGE > FRONT > SEAT BELTS since ownership vehicle has experienced intermittent stalling problems vehilce has been taken in for service numerous occassions without being repaired... |
1
|
SHOCK ABSORBER > FRONT > SUSPENSION rubber mount attached to bottom of frame is touching the spring causing vehicle to bottom out and front end to... |
1
|
COOLING UNIT AND LINES > AUTOMATIC TRANSMISSION > POWER TRAIN transmission leaked onto driveshaft causing a fire. dealer has repaired the vehicle.*ak... |
1
|
TORSION BAR > SPRINGS > FRONT while driving and when making a right or a left hand turn consumer has noticed a very loud knocking noise... |
1
|
SIDE/WINDOW > AIR BAGS when consumer's vehicle crashed into the side of a 92 mercury at about 45 mph there was no deployment of... |
1
|
AIR SUSPENSION SYSTEM > SPRINGS > FRONT when driving front end bounces up and down/ up and down. consumer has to slow down to keep control. consumer |
1
|
SERVICE BRAKES, ELECTRIC on 04/28/2000 i was towing my boat and trailer to lake erie on ohio state route 11 north when my... |
1
|
EXTERIOR > REARVIEW MIRRORS/DEVICES > VISIBILITY i contacted the ford hot line they said this is a normal condition. the blurred vision in thier side view... |
1
|
LINKAGES > STEERING shortly after purchase of vehicle steering changed steering wheel was off center. dealer discovered that left mounting bracket that holds... |
1
|
REARVIEW MIRRORS/DEVICES > VISIBILITY this vehicle shakes rattles and rolls constantly alignment 3 seperate times extremely hard too stop nothing but problems with frame... |
1
|
POWER ADJUST > FRONT ASSEMBLY > SEATS i own a 2000 ford excursion and have had problems with the rotors warping since new. the dealers have said... |
1
~ 10000 miles |
AXLE HUBS > POWER TRAIN i own a 2000 ford excursion and have had problems with the rotors warping since new. the dealers have said... |
1
~ 10000 miles |
BUCKLE ASSEMBLY > FRONT > SEAT BELTS consumer states that front seat belt on the passenger's side is stuck in the open position. seat belt will not |
1
|
HINGE AND ATTACHMENTS > TAILGATE > BODY consumer went to open upper part of liftgate and struts did not hold liftgate fell down. had not contacted dealer. |
1
|
TEMPORARY/EMERGENCY SPARE TIRE > TIRES the emergency tire cable broke which caused the tire to fall onto the street. *jb... |
1
|
TURBO/SUPERCHARGER > GASOLINE > ENGINE intermittently turbo-charger malfunctioned causing oil to leak from the vehicle and vehicle to stall. dealer has repaired the vehicle trhee |
1
|
Torque wrench
-
EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
-
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
-
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...
Mechanic tool set
-
Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
-
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
-
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
-
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
-
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
-
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...
Tool box
-
TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
-
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
-
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
-
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
-
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
-
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...
Discussion