Major Problems with 2002 Chrysler Voyager Derived from Complaints & Recalls

Custom-fit Add-ons

Torque wrench
Mechanic tool set
Tool box

Worst 3 complaints of 2002 Chrysler Voyager

2002 Chrysler Voyager ELECTRONIC STABILITY CONTROL Victims: 1 Mileage: 43000 miles

2002 Chrysler Voyager AIR BAGS Victims: 1 Mileage: 23363 miles

2002 Chrysler Voyager TIRES Victims: 1

Browse 2002 Chrysler Voyager complaints by category

Problems with AIR BAGS, SENSOR/CONTROL MODULE and AUTOMATIC TRANSMISSION are the most frequent issues recorded by the NHTSA from Chrysler Voyager owners.

Problem Category	Number of Problems
AIR BAGS airbag light stays on while driving.*ak...	13 ~ 12128 miles
SENSOR/CONTROL MODULE > FRONTAL > AIR BAGS i have had my airbag light come on for the second time now. after taking it to the dealer it...	9 ~ 32088 miles
AUTOMATIC TRANSMISSION > POWER TRAIN consumer took vehicle to dealer on 5 separate occassions regarding transmission failure. transmission was serviced and adjusted. however the defect	8 ~ 43173 miles
FUEL/PROPULSION SYSTEM tl* the contact owns a 2002 chrysler voyager. while driving at various speeds the contact noticed fuel fumes in the...	7 ~ 40149 miles
ELECTRICAL SYSTEM the front headlight was flashing on and off while parked in a parking lot (vehicle is not equip with an...	7 ~ 54291 miles
SERVICE BRAKES tl* the contact owns a 2002 chrysler voyager. the contact stated that the vehicle's brake seal fractured and caused the...	5 ~ 53201 miles
SERVICE BRAKES, HYDRAULIC consumer stated that while driving in inclement weather the back end of the vehicle locked up. this almost resulted in...	5 ~ 52635 miles
FRONTAL > AIR BAGS i have a chrysler voyager it was hit in the front the reson iam reporteing to you is that my...	5 ~ 28073 miles
TIRES while driving the right front tire blewout. *nlm...	4 ~ 17500 miles
ELECTRONIC STABILITY CONTROL want car inspected for defects. fuel rail leaking gas onto interior and exterior of vehicle. gas fumes come in through...	3 ~ 26012 miles
HOSE, PIPING, AND CONNECTIONS > HYDRAULIC POWER ASSIST > STEERING power steering hose failed. *jb...	3 ~ 9198 miles
STABILIZER BAR > FRONT > SUSPENSION dt*: the contact stated while driving various speeds on rough road conditions there was a banging noise coming from underneath...	2 ~ 25500 miles
EQUIPMENT i have 2 issues with my 2002 chrysler voyager. the first is the air bag light flashes on and off....	2 ~ 55000 miles
SUSPENSION shimmy in the front end. loss of control would be possible. strut mount is bad and so are sway bar...	2 ~ 35500 miles
STEERING shimmy in the front end. loss of control would be possible. strut mount is bad and so are sway bar...	2 ~ 18000 miles
REAR > SUSPENSION consumer stated that while driving in inclement weather the back end of the vehicle locked up. this almost resulted in...	2 ~ 47140 miles
HYDRAULIC POWER ASSIST SYSTEM > STEERING the vehicle (chrysler voyager 2002) had a total failure of its power steering and requires complete replacement of steering rack.	2 ~ 32000 miles
AIR CONDITIONER > APPLIANCE > EQUIPMENT when ac is turned on loud squealing noise comes from behind the dash. took it to dealer who had it	2 ~ 32500 miles
WINDSHIELD WIPER/WASHER > VISIBILITY windshield wipers caught onto each other i was able to make temp repair because of holding a safety inspection license...	2
SEAT BELTS seatbelt light came on. vehicle was taken to dealer 7 times before seatbelt was replaced.*ak...	2 ~ 36500 miles
BODY > STRUCTURE second time no brakes. fixed last year. brake fluid leaks out gas still leaking from circular piece not fixable. piece...	1 ~ 5 miles
FUEL SYSTEM, GASOLINE while driving suddenly brakes failed to work. hose broke all fluid leaked out. could not stop car. smelling strong odor...	1 ~ 60000 miles
UNKNOWN OR OTHER takata recall i own a 2002 chrysler voyager minivan. at about 85 000 miles i noticed the airbag light on...	1
SIDEWALL > TIRES from cold tires the vehicle traveled approximately 10 miles at varying speeds (30 - 60 mph). at that point the...	1
TREAD/BELT > TIRES tread separation from tire traveling at 20 mph. firestone supreme si p215/70r15. *tr...	1 ~ 70000 miles
STRUCTURE tl* the contact owns a 2002 chrysler voyager. the contact was attempting to change a tire when he was unable...	1 ~ 110000 miles
HARNESS/CROTCH BUCKLE > CHILD SEAT had vehicle 3 wks 1st problem took it back to dealer in pittsburgh ks. the sway bar bushing was wore...	1 ~ 73000 miles
MID/REAR ASSEMBLY > SEATS tl*the contact owns a 2002 chrysler voyager. the contact's vehicle was rear-ended while approaching a red light. the impact pushed...	1 ~ 125000 miles
LATCH > DOORS > LATCHES/LOCKS/LINKAGES latch on rear door of a 2002 chrysler voyager stopped operating properly. it does not stayed latched. the car was...	1 ~ 86543 miles
LATCHES/LOCKS/LINKAGES tl*the contact owns a 2002 plymouth voyager. the contact stated that the vehicle's locks are supposed to lock when driving...	1 ~ 66000 miles
HATCHBACK/LIFTGATE > BODY > STRUCTURE i have 2 issues with my 2002 chrysler voyager. the first is the air bag light flashes on and off....	1
HOOD > BODY > STRUCTURE i have 2 issues with my 2002 chrysler voyager. the first is the air bag light flashes on and off....	1
GEAR POSITION INDICATION (PRNDL) > AUTOMATIC TRANSMISSION > POWER TRAIN dt*: the contact stated while the vehicle is in park without the keys in the ignition the vehicle gear shifter...	1 ~ 121642 miles
TIE ROD ASSEMBLY > LINKAGES > STEERING 2002 chrysler voyager tie rod fell off of the rack and pinion while the vehicle was in motion. *mr the	1
TAIL LIGHTS > EXTERIOR LIGHTING consumers states: light fixture in the back on driver's side has been on however both back tail lights keep falling	1 ~ 56100 miles
MACPHERSON STRUT > FRONT > SUSPENSION shimmy in the front end. loss of control would be possible. strut mount is bad and so are sway bar...	1 ~ 36000 miles
RACK AND PINION > STEERING rack and pinion failed and was replaced with less then 60 000 miles. this is way to early and needs...	1 ~ 57500 miles
AXLE ASSEMBLY > POWER TRAIN dt: when braking or making a turn vehicle will lunge forward with the transmission and when backing out or driveing...	1 ~ 48000 miles
CHILD SEAT child safety seat failure recline adjusters broken off. *bf the consumer believed the seat was involved in a crash or	1
RECLINER > FRONT ASSEMBLY > SEATS while driving 35 mph the driver's seat collapsed unexpectedly. the driver was able to maintain control of the vehicle and	1
HEADLIGHTS > EXTERIOR LIGHTING while driving at night time with headlights on vehicle cut off without any prior warning leaving consumer without a vision	1 ~ 44000 miles
INTERIOR/UNDER DASH > WIRING > ELECTRICAL SYSTEM the instrument panel had become inoperative. the speedometer/gas gauge and oil pressure could not be seen neither day or night...	1
BUCKLE ASSEMBLY > FRONT > SEAT BELTS middle rear seat belt buckle does not lock. consumer has contacted dealer. *ak...	1
REAR/OTHER > SEAT BELTS on 2 separate occasions we have found our infant daughter's seat belt unbuckled with no explanation as to the cause...	1
ENGINE > ENGINE AND ENGINE COOLING while accelerating the engine lost power. *nlm...	1 ~ 9000 miles
COOLING UNIT AND LINES > AUTOMATIC TRANSMISSION > POWER TRAIN transmission fluid was leaking. vehicle at dealership at this time.*ak...	1
ANCHORAGE > FRONT > SEAT BELTS please recall the chrysler gen3 seatbelts. they have been tested by independant organizations and have been shown to unlatch during...	1
WARNING LIGHT/DEVICES > FRONT > SEAT BELTS seatbelt light came on. vehicle was taken to dealer 7 times before seatbelt was replaced.*ak...	1
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC when brakes are applied pedal has a delay in response from the system. owner states that brakes would either lock	1
RETRACTOR > FRONT > SEAT BELTS unsafe seat belts - requesting forced recall (gen 3 belts). *ak...	1
PADS > DISC > FOUNDATION COMPONENTS front brake pad is leaking a metallic substance causing a malfuction in pad resulting in brake pedal going all the	1
SEAT HEATER/COOLER > FRONT ASSEMBLY > SEATS after driving for a long time the passenger seat riser overheated at a high temperature that could burn passenger at...	1

Torque wrench

EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...

Mechanic tool set

Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...

Tool box

TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...