Major Problems with 2002 Chevrolet S-10 Derived from Complaints & Recalls


Custom-fit Add-ons



Worst 3 complaints of 2002 Chevrolet S-10

2002 Chevrolet S-10 FRONTAL Victims: 2

2002 Chevrolet S-10 HOSES, LINES/PIPING, AND FITTINGS Victims: 1

2002 Chevrolet S-10 HINGE AND ATTACHMENTS Victims: 1 Mileage: 40000 miles

Browse 2002 Chevrolet S-10 complaints by category

Problems with HINGE AND ATTACHMENTS, LATCH and ELECTRICAL SYSTEM are the most frequent issues recorded by the NHTSA from Chevrolet S-10 owners.

Problem Category Number of Problems
HINGE AND ATTACHMENTS > TAILGATE > BODY
while opening the tailgate both support tailgate cables broke. suddenly the tailgate dropped to the floor. the cause ha not
15
~ 41408 miles
LATCH > TAILGATE > LATCHES/LOCKS/LINKAGES
after lowering my s10 pick up truck tailgate i climbed onto it to get into the bed of the truck....
5
~ 48030 miles
ELECTRICAL SYSTEM
my fingers were burnned when i touched the inside right-side wall of the ash tray in my 2002 chevrolet s-10...
5
~ 23600 miles
LATCH > DOORS > LATCHES/LOCKS/LINKAGES
the third latch broke on the vehicle. *jb after being fixed the door opened but will not open or release
5
~ 57796 miles
AUTOMATIC TRANSMISSION > POWER TRAIN
at 90 degrees or above the vehicle will at times lose power to the transmission making entering traffic a safety...
5
~ 27730 miles
SUSPENSION
consumer states when driving above 50 mph the truck shakes violently. took to chevrolet and they stated this condition is
5
~ 80000 miles
FUEL PUMP > DELIVERY > FUEL SYSTEM, GASOLINE
fuel pump malfunctioned causing fuel to pump back into fuel tank. has caused a no start condition due to fuel
5
~ 35007 miles
SERVICE BRAKES
after i'd owned the vehicle for a little over 3 years and had only about 13 000 miles on it...
3
~ 70843 miles
12V/24V/48V BATTERY > ELECTRICAL SYSTEM
truck started stalling while at idol and when i put into drive. it as if it has no gas. *ak...
3
~ 33188 miles
FRONTAL > AIR BAGS
consumer was involved in a frontal collision at 35mph. upon impact air bags did not deploy resulting in driver sustaining
3
HINGE AND ATTACHMENTS > DOOR > BODY
the door opened fine all day and all of a sudden when i went to open the door it opened...
3
~ 61513 miles
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC
brakes are not working properly and there is extended stopping distance. at times vehicle will not stop at all. contacted
3
AIR BAGS
airbags failed to deploy when accelerator locked up on vehicle and consumer lost control. dealer contacted.*jb...
3
~ 17417 miles
ACCELERATOR PEDAL > VEHICLE SPEED CONTROL
while driving accelerator locked causing consumer to lose control of vehicle. contact dealer and general motors. vehicle totaled.*jb...
3
FRAME AND MEMBERS > STRUCTURE
the frame is bent. the vehicle has a problem with the alignment a week after being repaired. the vehicle has
3
~ 110000 miles
BODY > STRUCTURE
tl* the contact owns a 2002 chevrolet s10. while driving approximately 35 mph the spare tire located under the vehicle...
2
~ 89000 miles
STRUCTURE
i am the second owner of my s-10 zr2 the 3rd door has been unusable with substantial costs put into...
2
~ 65000 miles
LATCHES/LOCKS/LINKAGES
i am the second owner of my s-10 zr2 the 3rd door has been unusable with substantial costs put into...
2
TIRES
tl*the contact owns a 2002 chevrolet s10. the vehicle has four cooper sigma regent tires. while driving 60 mph the...
2
~ 49174 miles
PARKING BRAKE
dt*: the contact stated while driving 30 mph on dry road conditions an attempt was made to stop the vehicle...
2
~ 50240 miles
TAILGATE > BODY > STRUCTURE
dt: the contact states the tailgate cable broke during motion and the tailgate slammed down. this happened on 8-20-05. he...
2
~ 52272 miles
LOWER BALL JOINT > CONTROL ARM > FRONT
front bearing hubs have gone bad. this has happen only 3 000 after the extended warranty has expired at 100...
2
~ 91722 miles
DOOR > BODY > STRUCTURE
drivers side door leaks water and air. bad wind noise. *ak...
2
~ 25733 miles
HOSES, LINES/PIPING, AND FITTINGS > DELIVERY > FUEL SYSTEM, GASOLINE
driver fell asleep while driving 75 mph vehicle left the road rolled a few times and caught on fire. driver...
2
~ 98500 miles
TANK ASSEMBLY > STORAGE > FUEL SYSTEM, GASOLINE
multiple parts replaced with no success - sending unit level sensor gauge etc. mr...
2
~ 31925 miles
RECLINER > FRONT ASSEMBLY > SEATS
passenger seat does not lock in place until pushed all the way back-cannot do that if someone is in the
2
~ 24000 miles
VEHICLE SPEED CONTROL
consumer has brought vehicle back to the dealership three times for a creaking noise heard in the front end. also...
2
AIR CONDITIONER > APPLIANCE > EQUIPMENT
consumer has brought vehicle back to the dealership three times for a creaking noise heard in the front end. also...
2
~ 40000 miles
POWER TRAIN
in cold weather the rubber boot on the manual transmission shift lever gets so stiff that it will force the...
2
~ 95000 miles
LABELS > OTHER > EQUIPMENT
the consumer stated that the console/arm rest (in the open position) will expel the contents from the cavity onto the
2
SIDE/WINDOW > AIR BAGS
as a result of a side impact crash the side air bag deployed. please provide estimated speed and further information.
2
~ 32705 miles
ENGINE AND ENGINE COOLING
2002 chevrolet s-10. consumer writes in regards to oil leaking onto the manifold. *ld...
1
TREAD/BELT > TIRES
i bought a set of goodyear viva 2 tires at walmart. i have less than 30k miles on them. i...
1
TIE ROD ASSEMBLY > LINKAGES > STEERING
1999 chevrolet s10 driveworks steering inner tie rod end part no. dw-es3380t. right against the front cross member on my...
1
ENGINE
had a check engine light at a startup. code was p0305. seen many owners are having this problem and many...
1
~ 161126 miles
HINGE AND ATTACHMENTS > HATCHBACK/LIFTGATE > BODY
tl*the contact owns a 2002 chevrolet s10. while driving approximately 10 mph and exiting a parking lot the contact heard...
1
~ 49000 miles
EQUIPMENT
i am the second owner of my s-10 zr2 the 3rd door has been unusable with substantial costs put into...
1
UNDERBODY SHIELDS > FRAME AND MEMBERS > STRUCTURE
i have a 2002 chevrolet s10 zr2. it has had many problems in the front end it was eventually discovered...
1
~ 80000 miles
SERVICE BRAKES, HYDRAULIC
dt*: the contact stated while driving 30 mph on dry road conditions an attempt was made to stop the vehicle...
1
~ 40000 miles
DRIVELINE > POWER TRAIN
2002 chevy s-10 crew cab rear axle failure failure due to water in axle housing due to vent pipe being...
1
~ 175000 miles
REAR/OTHER > SEAT BELTS
dt*: the contact stated that 9 months ago the seat belt fractured. the female portion of the buckle would not...
1
~ 65000 miles
UNKNOWN OR OTHER
i noticed one of the tailgate cables on my 2002 cheverolet s-10 pickup (45 000 miles) appeared to be streached....
1
~ 45000 miles
INJECTORS > FUEL INJECTION SYSTEM > FUEL SYSTEM, GASOLINE
truck started stalling while at idol and when i put into drive. it as if it has no gas. *ak...
1
~ 24324 miles
AXLE HUBS > POWER TRAIN
front bearing hubs have gone bad. this has happen only 3 000 after the extended warranty has expired at 100...
1
~ 103444 miles
UPPER BALL JOINT > CONTROL ARM > FRONT
front bearing hubs have gone bad. this has happen only 3 000 after the extended warranty has expired at 100...
1
~ 103444 miles
HINGE AND ATTACHMENTS > HOOD > BODY
2002 chevrolet s-10 crew cab tailgate cables broke. bf the consumer was standing on the tailgate when the incident occurred.
1
~ 45000 miles
INTERIOR LIGHTING
warning light does not come on when doors are ajar truck is a crew cab. has child safety locks. *ak...
1
~ 18000 miles
ANTILOCK > SERVICE BRAKES, AIR
-brakes failed to stop vehicle (2002 cherolet s10 pickup) while traveling at low speed (20-35 mph). brake pedal went to...
1
~ 7580 miles
HEADLIGHTS > EXTERIOR LIGHTING
headlights do not stay adjusted causing impaired vision. dealer has repaired defect over six times but problem still exists. *ak...
1
~ 40000 miles
DIFFERENTIAL UNIT > DRIVELINE > POWER TRAIN
initial complaint started at approx 17 100 miles. there was water reported in the rear end differential. dealer (lucas chevrolet)...
1
~ 23200 miles
SWITCH > HEADLIGHTS > EXTERIOR LIGHTING
pushing the dome light over ride button twice turns off the headlights. this can make you panic untill you switch
1
HOOD > BODY > STRUCTURE
driver feels that the design and location of the hood release lever causes foot to make contact with lever when
1
ROTOR > DISC > SERVICE BRAKES, AIR
right rear brake would not release completely cause brakeing and warning light to illuminate dealer notified and unable to determined
1
REAR > SUSPENSION
while driving on the highway back of vehicle will bounce. driver almost lost control of vehicle.*ak...
1
MODULE > IGNITION > ELECTRICAL SYSTEM
vehicle has stalled 4 times at various speeds. taken to dealer 4 times fuel module/fuel filter and instrument cluster were...
1
AXLE ASSEMBLY > POWER TRAIN
at 35mph axle snapped. causing vehicle to pull to left. cause unknown. dealer notified.*ak...
1
FRONT > SUSPENSION
reporting intermittentley problem with a popping noise from the right front supension dealer is aware of the problem. ts...
1
SEATS
the seat failure just occurred while my wife was in the truck. the seat unexpectantly shifted back while drivng in...
1
FUEL SYSTEM, GASOLINE
computer chip constantly fails which causes a chain reaction of failures to occur. the truck is unreliable with various brake...
1

Torque wrench

  • EPAuto 1/2-inch Drive Click Torque Wrench, 10~150 ft./lb., 13.6 ~ 203.5 N/m

    EPAuto 1/2-inch Drive Click Torque Wrenc...

    • Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
    • Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
    • Easy to Read: High...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 10~150 Ft-Lb/13.6~203.5 Nm (LX-183)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
    • LONGEVITY -...
  • LEXIVON 1/2-Inch Drive Click Torque Wrench 25-250 Ft-Lb/33.9-338.9 Nm (LX-184)

    LEXIVON 1/2-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON 3/8-Inch Drive Click Torque Wrench 10~80 Ft-Lb/13.6~108.5 Nm (LX-182)

    LEXIVON 3/8-Inch Drive Click Torque Wren...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • LEXIVON Inch Pound Torque Wrench 1/4-Inch Drive | 20~200 in-lb/2.26~22.6 Nm (LX-181)

    LEXIVON Inch Pound Torque Wrench 1/4-Inc...

    • PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
    • DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
    • LONG-LASTING...
  • TEKTON 3/8 Inch Drive Micrometer Torque Wrench (10-80 ft.-lb.) 24330

    TEKTON 3/8 Inch Drive Micrometer Torque ...

    • Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
    • Wrench emits a click that can be heard and felt when the preset value is reached
    • Permanently marked, high-contrast dual-range...

Mechanic tool set

  • Crescent 180 Pc. Professional Tool Set in Tool Storage Case - CTK180

    Crescent 180 Pc. Professional Tool Set i...

    • The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
    • Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
    • Get incredible access from combination wrenches with narrow heads,...
  • Craftsman Mechanic Tool Set, 215 Piece, Hand Box Set in Metal, 3 Drawers, Red (CMMT45303)

    Craftsman Mechanic Tool Set, 215 Piece, ...

    • MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
    • VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
  • Craftsman Mechanic Tool Set, 230 Piece with 3 Drawers, Sockets, Extension Bars, Wrenches, Hex Keys, and More (CMMT45305)

    Craftsman Mechanic Tool Set, 230 Piece w...

    • TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
    • OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
  • DEWALT Mechanics Tool Set, 1/4' & 3/8' & 1/2' Drive, SAE/Metric, 205-piece (DWMT81534)

    DEWALT Mechanics Tool Set, 1/4" & 3/8" &...

    • 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
    • Anti-slip driver handle provides maximum comfort
    • Housed in a durable carrying case with metal latches
    • Full-polish chrome for corrosion resistance
  • DEWALT Mechanics Tools Kit and Socket Set, 142-Piece, 1/4 & 3/8' Drive, MM/SAE (DWMT73802)

    DEWALT Mechanics Tools Kit and Socket Se...

    • Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
    • Ratchets include a low profile directional lever to help reduce catch points and for easy...
  • Amazon Basics Mechanic's Tool Set with Chrome Finish and Case - Set of 201 Pieces

    Amazon Basics Mechanic's Tool Set with C...

    • Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
    • Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
    • Both metric...

Tool box

  • TUFFIOM 8-Drawer Rolling Tool Chest w/Lock & Key, Tool Storage Cabinet w/Wheels, Detachable Top, Drawers, Side Hooks & Drawer Liners, Tool Organizer Box for Garage, Warehouse & Repair Shop, Red

    TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...

    • LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
  • beyond by BLACK+DECKER BLACK+DECKER BDST60500APB Stackable Storage System - 3 Piece Set (Small Toolbox, Deep Toolbox, and Rolling Tote)

    beyond by BLACK+DECKER BLACK+DECKER BDST...

    • Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
    • Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
  • BIG RED ANTBD133-XB Torin 20' Portable 3 Drawer Steel Tool Box with Metal Latch Closure, Red

    BIG RED ANTBD133-XB Torin 20" Portable 3...

    • Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
    • Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
  • DEKOPRO 228 Piece Socket Wrench Auto Repair Tool Combination Package Mixed Tool Set Hand Tool Kit with Plastic Toolbox Storage Case

    DEKOPRO 228 Piece Socket Wrench Auto Rep...

    • HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
    • COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
  • Torin 17-Inch Plastic Tool Box,3-Tiers Multi-Function Storage Portable Toolbox Organizer, Black/Orange ATRJH-3430T

    Torin 17-Inch Plastic Tool Box,3-Tiers M...

    • Tough metal latches are solid and easy to open and close, with long use life
    • Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
  • CARTMAN 148 Piece Automotive and Household Tool Set - Perfect for Car Enthusiasts and DIY Home Repairs

    CARTMAN 148 Piece Automotive and Househo...

    • Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
    • Durable and Corrosion-Resistant: All tools in the kit...


2002 Chevrolet S-10 specs
Compare

Exterior

Bulbs

Maintenance

Complaints

Forgive our ad-diction! It's just our funky little way of keeping the lights on. Bear with us!

Discussion