Major Problems with 2000 Chevrolet Express Derived from Complaints & Recalls

Custom-fit Add-ons

Torque wrench
Mechanic tool set
Tool box

Worst 3 complaints of 2000 Chevrolet Express

2000 Chevrolet Express POWER ADJUST Victims: 1

2000 Chevrolet Express SEATS Mileage: 54920 miles

2000 Chevrolet Express STRUCTURE Mileage: 100000 miles

Browse 2000 Chevrolet Express complaints by category

Problems with ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP, TREAD/BELT and SEATS are the most frequent issues recorded by the NHTSA from Chevrolet Express owners.

Problem Category	Number of Problems
ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP > SERVICE BRAKES, HYDRAULIC major problem with braking system. company will not fix. *ak...	9
TREAD/BELT > TIRES this is a fleet repair facility for consumers energy. i have had 4 tread separations on chevrolet express vans in...	8
SEATS while driving track bolts broke for the second time. contacted dealer and the dealer cannot find a remedy.*ak the power	5 ~ 23584 miles
TIRES driving i-10 between pheonix and blythe at early night. right rear tire blewout with no warning at 75 mph.*ak (tiresize:	4
POWER ADJUST > FRONT ASSEMBLY > SEATS my wife was sitting in the driver seat of the van. the van was parked. her leg made contact with...	4 ~ 21227 miles
HINGE AND ATTACHMENTS > DOOR > BODY side door hinges are stiffing up.tried oiling numerous times.door is very hard to open and close.if something would happen my	4 ~ 108250 miles
AUTOMATIC TRANSMISSION > POWER TRAIN 2000 chevrolet express van problems with intermittent downshifting from gear 4 to gear 3 for no apparent reason. transmission has	3 ~ 67590 miles
FRONT > SUSPENSION there is a clunking noise when applying brakes at speeds of 20 mph and under on both corners of front	3
FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC vehicle has been in repair shop three times pertaining to brake pads . brake pads are too weak and there...	3
FUEL GAUGE SYSTEM > STORAGE > FUEL SYSTEM, OTHER gas gauge is defective. it may indicate a full tank but actually it is less. *ak...	3 ~ 38333 miles
SERVICE BRAKES, HYDRAULIC while driving the driver and passenger side seat snapped off the base on different occasions. *ak the seat belts unlatched...	2 ~ 37460 miles
RETRACTOR > FRONT > SEAT BELTS dealer had to replace seat belt retractor two times because it failed to lock properly 2nd row seat driver's side.	2
BUCKLE ASSEMBLY > FRONT > SEAT BELTS consumer's church bus was affected by recall 00e048000. however dealership was only able to repair 2 of 30+ seat belt...	2
EXTERIOR > REARVIEW MIRRORS/DEVICES > VISIBILITY both of exterior mirrors would severely shake while traveling at highway speed of 55 mph or more it causes problem...	2 ~ 27460 miles
DISC > FOUNDATION COMPONENTS > SERVICE BRAKES, HYDRAULIC front brakes are wearing out prematurely it causes front wheel to lock up. dealer notified. feel free to provide any	2
ANCHORAGE > FRONT > SEAT BELTS the rear shoulder belts cross the seated adult occupant on his/her neck. on a child the belt crosses the child's...	2
ELECTRICAL SYSTEM the dashboard caught on fire. due to electrical system failure. *jb...	2 ~ 50750 miles
WHEELS gladiator conversion there is problem with right wheel which is causing both brakes to wear out every 1500 to 1800	2
SERVICE BRAKES 1 of many issues with this van. 62000 miles. rear brake line blew luckily in my driveway. upon inspection all...	1 ~ 62700 miles
REAR/OTHER > SEAT BELTS 2000 chevrolet 12 passenger express van: one of the seat belts in the vehicle has been replaced 3 times and...	1
RECLINER > FRONT ASSEMBLY > SEATS dt: the contact owns a 2000 chevrolet express. the drivers seat is broken. two days ago i realized that the...	1 ~ 95500 miles
BRAKE LIGHTS > EXTERIOR LIGHTING the ground wire on the rear brake light socket comes loose. when the head lights are off this causes the...	1
SIDEWALL > TIRES tl*the contact owns a 2000 chevrolet express. the vehicle has goodyear ultra metric bst radial tires (na). while driving 40...	1
COLUMN > STEERING 2000 chevorlet van w/28128 miles had power stearing column break causing vehicle to be towed because of being unable to...	1 ~ 28128 miles
HOSE, PIPING, AND CONNECTIONS > HYDRAULIC POWER ASSIST > STEERING dt: the contact owns a 2000 chevrolet express. recall 00v085000 concerning power assist hose piping and connections was issued. some...	1
PUMP > HYDRAULIC POWER ASSIST > STEERING on a recent trip to the nc mountains i was negotiating a curve and had a complete loss of power...	1 ~ 56750 miles
RADIATOR ASSEMBLY > COOLING SYSTEM > ENGINE AND ENGINE COOLING we purchased a chevrolet express van brand new in august 2000 and from day one we have had problems with...	1
LATCH > DOORS > LATCHES/LOCKS/LINKAGES 2000 chevrolet express conversion van side cargo door hinge of the rear door rusted causing the door to fall off...	1 ~ 73800 miles
FRONTAL > AIR BAGS while driving 15 mph both frontal air bags went off inadvertently. consumer was able to drive the vehicle to the...	1
FUEL INJECTION SYSTEM > FUEL SYSTEM, OTHER dt: the contact stated while driving the vehicle it stalled intermittently. the vehicle stalled when slowing down or when stopping....	1 ~ 99064 miles
STRUCTURE while driving and or parking it was difficult for the consumer to roll the windows up or down on the...	1 ~ 100000 miles
POWER WINDOW DEVICES AND CONTROLS > VISIBILITY while driving and or parking it was difficult for the consumer to roll the windows up or down on the...	1 ~ 100000 miles
SENSOR/CONTROL MODULE > FRONTAL > AIR BAGS air bag light is on on dashboard. chevrolet had installed the airbag sensor on the floor under the drivers seat...	1
CATALYTIC CONVERTOR > EMISSION CONTROL > EXHAUST SYSTEM 2000 chevrolet express van 1500 va 4.3 liter. catalytic converter fails dealer says the internals completely break up. have had...	1 ~ 18000 miles
IGNITION > ELECTRICAL SYSTEM vehicle stalls while driving at speeds 60 mph or more restart and stops again this can happen at any time.	1
WHEEL BEARING > FRONT > SUSPENSION while driving front brakes would get too hot causing extended stopping distance. dealer has been notified. *ak the passenger front...	1
TEMPORARY/EMERGENCY SPARE TIRE > TIRES the rear passenger side tire tread separated. consumer changed the tire and the spare tire started to violently vibrate while...	1
POWER TRAIN nar 1/15/2003. the consumer stated the vehicle had an intermittent deceleration problem. at times there was no engine hold back...	1
DOOR > BODY > STRUCTURE while driving the driver and passenger side seat snapped off the base on different occasions. *ak the seat belts unlatched...	1 ~ 54920 miles
SEAT BELTS while driving the driver and passenger side seat snapped off the base on different occasions. *ak the seat belts unlatched...	1 ~ 54920 miles
DELIVERY > FUEL SYSTEM, GASOLINE consumer stated while driving and without warning the fuel sending unit failed and shut off. dealer notified. ts tt jb...	1 ~ 60610 miles
LATCH > TAILGATE > LATCHES/LOCKS/LINKAGES consumer states the tailgate doors do not have a retainer latch to keep them from swinging too far outward(perpendicular to...	1
ROTOR > DISC > FOUNDATION COMPONENTS there was vibration when applying brakes. front rotors have been turned once then replaced due to warping.*ak...	1
BODY > STRUCTURE i own 2000 chevy express 2500 passenger van. i bought the van new from the dealer and within two years...	1
UPPER ARM > CONTROL ARM > FRONT while driving 30 mph ball joints broke from vehicle with no prior warning. consumer lost control of vehicle and hit...	1
UNKNOWN OR OTHER this van has a slow down mode that varies. when reached at a steady 55mph the gas pedal was released...	1 ~ 17000 miles
HYDRAULIC POWER ASSIST SYSTEM > STEERING when traveling there is no certain speed and steering is hard to steer. when applying brakes vehicle doesn't stop results	1
VEHICLE SPEED CONTROL van fails to decelerate when accelerator pedal is released making it difficult to stop in an appropriate distance. very unsafe	1
PADS > DISC > FOUNDATION COMPONENTS braking system malfunctioned which caused more wear and tear on brake pads resulting in extended stopping distance. *ak the premature	1
MODULE > IGNITION > ELECTRICAL SYSTEM consumer's new 2000 vehicle which has a rv on a chevrolet chassis engine stalls out at will in the heat....	1
STEERING while driving the steering system malfunctioned causing the steering wheel to be loose and move freely which may cause a...	1
EXHAUST SYSTEM > ENGINE AND ENGINE COOLING no summary listed for abov evehicle. *ak...	1
AXLE ASSEMBLY > POWER TRAIN no summary listed for abov evehicle. *ak...	1
PEDALS AND LINKAGES > SERVICE BRAKES, HYDRAULIC poor design of the brake pedal caused the drivers foot to slip off the brake consumer had the pedal extended.	1
COIL SPRINGS > SPRINGS > FRONT gladiator conversion there is problem with right wheel which is causing both brakes to wear out every 1500 to 1800	1

Torque wrench

EPAuto 1/2-inch Drive Click Torque Wrenc...
- Durable Ratchet Head: Made from Hardened treated Chrome Vanadium steel alloy (Cr-V) Corrosion-Retardant: Satin Finish. Made in Taiwan
- Easy Storage: A sturdy plastic storage case is included. Non-Slip Grip: Knurled handle
- Easy to Read: High...
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISE - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat-treated Chrome Vanadium alloy steel.
- LONGEVITY -...
LEXIVON 1/2-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
LEXIVON 3/8-Inch Drive Click Torque Wren...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
LEXIVON Inch Pound Torque Wrench 1/4-Inc...
- PRECISION - Ships pre-calibrated to +/- 4% accuracy and ready to use. Include calibration certificate with traceable serial number.
- DURABLE - Reinforced ratchet gear head constructed from hardened, heat treated Chrome Vanadium alloy steel.
- LONG-LASTING...
TEKTON 3/8 Inch Drive Micrometer Torque ...
- Includes 1-pc. 3/8 in. drive torque wrench; Storage case; Product manual with torque conversion chart
- Wrench emits a click that can be heard and felt when the preset value is reached
- Permanently marked, high-contrast dual-range...

Mechanic tool set

Crescent 180 Pc. Professional Tool Set i...
- The Crescent Professional Tool Set has a newly designed 72T quick release ratchet
- Carefully selected assortment of hand tools for most industrial, mechanical, and consumer applications
- Get incredible access from combination wrenches with narrow heads,...
Craftsman Mechanic Tool Set, 215 Piece, ...
- MINIMAL ARCH SWING: 72-tooth 1/4 in. and 3/8 in. Drive Ratchets produce a 5-degree arc swing. Ideal balance between access and durability.
- VERSATILE: Comprehensive set of 1/4 in., 3/8 in. Drive Sockets and Drive Tool...
Craftsman Mechanic Tool Set, 230 Piece w...
- TACKLE A VARIETY OF PROJECTS: Complete automotive jobs and general mechanic fixes with this heavy-duty, 230-piece all-in-one mechanic tool set
- OPEN AND CLOSE THE DRAWERS WITH ONE HAND as you work with a spring-loaded locking...
DEWALT Mechanics Tool Set, 1/4" & 3/8" &...
- 72 tooth count ratchet providing a 5 degree arc swing for maneuverability in restricted areas
- Anti-slip driver handle provides maximum comfort
- Housed in a durable carrying case with metal latches
- Full-polish chrome for corrosion resistance
DEWALT Mechanics Tools Kit and Socket Se...
- Socket sets include 72 tooth count ratchets which allow for a 5 degree arc swing for maneuverability in restricted areas
- Ratchets include a low profile directional lever to help reduce catch points and for easy...
Amazon Basics Mechanic's Tool Set with C...
- Mechanic tool kit and socket set for tackling multiple sizes and types of fasteners, especially nuts and bolts
- Includes a 201-piece set that combines most popular sockets, wrenches, hex keys, and screwdriver bits
- Both metric...

Tool box

TUFFIOM 8-Drawer Rolling Tool Chest w/Lo...
- LARGE STORAGE CAPACITY: The rolling tool chest is designed with 8 drawers and 1 bottom cabinet for storing tools, small equipment or other objects. And the bottom cabinet features side hooks for hanging tools like...
beyond by BLACK+DECKER BLACK+DECKER BDST...
- Sturdy + Stackable: Durable Auto-Lock Latches Make Connecting These Stackable Units Quick And Easy
- Quick Access: The Quick-Release On The Locking Latch Allows You To Easily Separate Each Module When Stacked For Quick Access To...
BIG RED ANTBD133-XB Torin 20" Portable 3...
- Heavy duty tool box is made of thick steel, with powder coat red paint finish, beautiful and easy to clean
- Measures 20.5" L x 8.5" W x 12" H, and is equipped with 3 drawers...
DEKOPRO 228 Piece Socket Wrench Auto Rep...
- HIGH QUALITY&STANDARDS:Forged from high-quality steel and finished in high-polish chrome,strength, durability, anti-corrosion protection.All the tools meet or exceed ANSI critical standards
- COMPLETE VARIETIES:Contains tools needed for most small repairs and basic DIY projects around the...
Torin 17-Inch Plastic Tool Box,3-Tiers M...
- Tough metal latches are solid and easy to open and close, with long use life
- Foldable three-tier tray provides you with more storage space and you can separate metric and imperial tools to take them...
CARTMAN 148 Piece Automotive and Househo...
- Comprehensive Tool Set: The Cartman 148-Piece Tool Kit includes all the crucial tools needed for everyday home repairs and maintenance, from cutting to tightening, measuring to hammering.
- Durable and Corrosion-Resistant: All tools in the kit...